Next Article in Journal
Removal of Quinolone Antibiotics from Wastewater by the Biochar-Based Sludge Adsorbent
Next Article in Special Issue
Recovery of Energy and Carbon Dioxide from Craft Brewery Wastes for Onsite Use
Previous Article in Journal
Changes in the Concentration of Amino Acids and Bacterial Community in the Rumen When Feeding Artemisia absinthium and Cobalt Chloride
Previous Article in Special Issue
Induced Autolysis of Engineered Yeast Residue as a Means to Simplify Downstream Processing for Valorization—A Case Study
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Modelling of Amino Acid Fermentations and Stabilization of Anaerobic Digestates by Extracting Ammonium Bicarbonate

by
Alejandro Moure Abelenda
*,
George Aggidis
and
Farid Aiouache
School of Engineering, Lancaster University, Lancaster LA1 4YW, UK
*
Author to whom correspondence should be addressed.
Fermentation 2023, 9(8), 750; https://doi.org/10.3390/fermentation9080750
Submission received: 4 July 2023 / Revised: 30 July 2023 / Accepted: 9 August 2023 / Published: 12 August 2023
(This article belongs to the Special Issue Sustainable Development of Food Waste Biorefineries)

Abstract

:
With the current increase in demand for animal and agricultural products, management of agrowaste has become critical to avoid greenhouse gas emissions. The present article investigates the applicability of ammonium bicarbonate synthesis via flash distillation to valorize and stabilize several types of anaerobic digestates which are produced from individual fermentations of amino acids. The content of CO2 in the digestate was found to be responsible for the OH alkalinity (0.4 equivalents of acid/kg digestate), while the partial and total alkalinities (0.8 eq/kg digestate) were essentially derived from the content of NH3. The most suitable conditions for the flash distillation were 95 °C and 1 bar with the condensation occurring at 25 °C. However, in order to attain the precipitation of NH4HCO3 in the distillate, it was necessary to consider digestates with a moisture content of 50 wt.%, since saturation levels of inorganic nitrogen and inorganic carbon were not attained otherwise. Even under these conditions, few amino acids (i.e., arginine, glycine, and histidine) were able to provide an anaerobic digestate upon fermentation that would be suitable for NH4HCO3 stabilization. The process of stabilization with a capacity of a t of digestate per h was improved by adding hydrochloric acid or sodium hydroxide at a rate of 44 kg/h, leading to production of 34 kg NH4HCO3/h. Given the role of the volatile elements of the biogas as endogenous stripping agents, it is recommended to use a fresh and saturated digestate as feed for the flash distillation.

Graphical Abstract

1. Introduction

Anaerobic digestion (AD) is one the most promising technologies for reliable production of clean energy [1]. According to Patel et al. [2], AD has the potential to convert up to 95 wt.% of organic matter to biogas. The valorization of waste by means of this fermentative process enhances the circular economy because most of the nutrients required for cultivation of crops end up in the organic residue (i.e., anaerobic digestate), which is mainly applied to land as organic soil amendment and reduces the consumption of industry-based inorganic fertilizers [3]. The mineralization of organic nutrients during AD implies that these become more readily available to plants but also that they can be easily lost via volatilization and leaching during the management of organic manures. Current regulations in force prescribe closing slurry stores and the use of low-emission spreading techniques at the time of land application, which should be done at specific locations and during the right season [4]. It is also possible to carry out the isolation of the nutrients, for example, by precipitating the struvite (i.e., magnesium ammonium phosphate). This open-loop management strategy requires prior solid–liquid separation of the anaerobic digestate, an external source of magnesium [5], and often additional phosphate to be able to deplete the ammoniacal nitrogen (NH4+-N) initially contained in the aqueous solution [6,7]. The formation of ammonium carbonate in the anaerobic digestate has been traditionally reported as one of the phenomena that increase and regulate the pH during anaerobic fermentation [8]; therefore, this could be among the most efficient routes for the isolation of NH4+-N.
The ammonium bicarbonate process (known as ABC) [9,10,11] is, therefore, considered a more sustainable alternative for recovering ammonia, compared with other processes involving the use of exogenous scrubbing agents, such as sulfuric acid [12], and the operation of expensive equipment with high energy demand, such as an air blower [13]. Hence, the stabilization of anaerobic digestate by means of NH4HCO3 synthesis has gained attention as a promising profitable technology [13]. Unlike open-loop processes, the patented ABC [9] offers a synergistic approach in which biogas with a composition of 65 vol.% CH4 and 35 vol.% CO2 [14] is efficiently used as a scrubbing agent of the stripped gas. In this process, the pH of the liquid fraction of the anaerobic digestate is adjusted to 11.5 via addition of NaOH to reduce 10 times its content of total ammonia (from 800 to 80 mg/L), using the NH3&CO2-depleted biogas (i.e., biomethane grade or 99 vol.% CH4) as stripping gas. Subsequently, the resulting stripped gas is mixed with 58 vol.% of the fresh biogas, originally produced in the AD, to promote the precipitation of NH4HCO3 and produce the biomethane stream. In addition to the NH3&CO2-depleted/stabilized liquid digestate and the solid crystals of NH4HCO3, the purges of 42 vol.% fresh biogas and 1 vol.% biomethane (these percentages refer to the total volume of the streams generated in the steps of anaerobic digestion and NH4HCO3 precipitation, respectively) could be regarded as valuable outputs of the ABC. The 99 vol.% of the biomethane generated in the step of NH4HCO3 precipitation is recirculated and employed as stripping gas. The role of the CH4 in the ABC is not clear [9], nor whether the use of the biomethane as stripping gas affects (a) the volatilization of NH3 from the alkalinized liquid digestate and (b) the subsequent NH4HCO3 precipitation during the contact of the stripped gas with the fresh biogas.
In the distillation process engineered by Drapanauskaite et al. [13] for the production of NH4HCO3 from the liquid fraction of an anaerobic digestate, the release of CH4 was not accounted in the liquid distillate stream obtained at the top of the column at 3 bar and 49 °C (89.0 vol.% H2O, 5.0 vol.% HCO3, 5.0 vol.% NH4+, 0.3 vol.% CO2, 0.1 vol.% NH3, 0.3 vol.% NH2COO, and 0.1 vol.% CO32−). It is noteworthy that the Henry’s law volatility constant of methane (71.43·103 Pa·m3·mol−1) is greater than those of ammonia (1.69 Pa·m3·mol−1) and carbon dioxide (3.03·103 Pa·m3·mol−1) in an aqueous solution [15]. It should be noted that since NH3 and CO2 behave like non-condensable gases under the normal operating conditions of the distillation, Henry’s law is preferred to Raoult’s law to describe this two-step system: degasification and absorption. This agrees with the fact that less than 1% of the NH4+-N is volatilized as part of the biogas release during the AD [8]. In the condensed distillate at 3 bar and 49 °C and in the uncondensed purge there were shares of 0.2 vol.% and 0.3 vol.%, respectively, that were not identified and could be attributed to methane [13]. It is important to account for the release of any gas during the NH4HCO3 synthesis because this can have a significant effect on the residual biogas potential of the stabilized digestate, for which an upper limit of 250–450 mL/g volatile solids is considered [16,17,18].
The present article investigates whether NH4HCO3 manufacturing technology via flash distillation is suitable for any composition of anaerobic digestate or whether some requirements need to be introduced at the stage of selecting the feedstock for AD. It is proposed to further expand the process simulation model by Rajendran et al. [19] for AD while minimizing the heat requirements for the flash distillation, in agreement with the approach followed by Centorcelli et al. [20,21]. Therefore, this investigation supports and advances the 7th (affordable and clean energy) and 13th (climate action) Sustainable Development Goals of the United Nations. The closed-loop process, where the CO2 is valorized as absorbent of the NH3 for synthesis of NH4HCO3, is relevant for agroindustry and the chemical fertilizer industry.

2. Materials and Methods

Following the methodology of Drapanauskaite et al. [13], prior to the development of the models in Aspen Plus® v12, the simulation was validated by comparing the empirical data available in the literature to the values provided by the software for the partial pressures of NH3 and CO2 in an aqueous system at the bubble point. Similarly, the supersaturation of the aqueous system in NH4HCO3, NH4COONH2, NaHCO3, and NH4Cl was also tested to ensure that the formation of solid phases was closely monitored in the flash distillation process. A model digestate was elaborated (Table A1) with the descriptions by Rajendran et al. [19] and Akhiar et al. [22] to verify the simulation of adding acids or bases to shift the chemical equilibria, following the titration methodology of Moure Abelenda et al. [23]. When it was confirmed that the system CO2-NH3-H2O was modelled correctly, the minimum conditions for the production of NH4HCO3 were investigated with the calculation block of the flash tank and using the electrolyte non-random two-liquid (ELECNRTL) property method. The ELECNRT method is defined by Aspen Plus® as versatile and capable of handling both very low and high concentrations of solutes in aqueous systems and other solvents. The first step was to determine the optimum temperatures for flash separation and condensation, to handle a tonne of digestate per hour with typical composition of 2 g/L of NH3 and 3 g/L of CO2 [22]. This processing capacity was selected based on the subsidies available for covering 40% of the total cost of the equipment dealing with slurry separation [24]; hence, a wider adoption by the stakeholders of agroindustry can be expected. The synthesis of NH4HCO3 was subsequently confirmed by a parametric study and the minimum feasible conditions (i.e., concentration of NH3 and CO2 and temperature of the flash distillation) were readjusted. In order to select the most suitable types of anaerobic digestates for the manufacturing of NH4HCO3, the minimum concentrations of NH3 and CO2 were matched to streams coming out of the anaerobic digestion of amino acids. These amino acids were set as the lower limit for the composition of the feedstock employed for the anaerobic digestion, as the presence of any other type of molecule would result in a diluted stream with lower concentrations of inorganic nitrogen and carbon, which would constrain the production of NH4HCO3 by the flash distillation process. The stoichiometry and the kinetics for amino acid anaerobic fermentation were mostly taken from the previous investigation by Rajendran et al. [19], except for the fermentation of glutamine (Equation (1)) which was proposed in a similar fashion to the degradation of the other amino acids. The production of oxygen in some of these reactions implies that they are only spontaneous under strongly reducing conditions and would be very limited under aerobic conditions (Le Chatelier’s principle). It is important to mention that the type of model that was used for the AD was unstructured and unsegregated, which implies that it did not involve the metabolism of the microorganisms nor differentiate the species that degraded the biomass [25].
C 5 H 10 N 2 O 3 + 3 H 2 O 2 C 2 H 4 O 2 + C O 2 + 2 N H 3 + H 2
C 2 H 5 N O 2 + 0.5 H 2 O 0.75 C 2 H 4 O 2 + N H 3 + 0.5 C O 2
C 2 H 5 N O 2 + H 2 O C 2 H 4 O 2 + N H 3 + 0.5 O 2
C 4 H 9 N O 3 + H 2 O C 3 H 6 O 2 + N H 3 + H 2 + C O 2
C 4 H 9 N O 3 + H 2 O C 2 H 4 O 2 + 0.5 C 4 H 8 O 2 + N H 3 + 0.5 O 2
C 6 H 9 N 3 O 2 + 5 H 2 O C H 3 N O + 2 C 2 H 4 O 2 + 2 N H 3 + C O 2 + H 2
C 6 H 9 N 3 O 2 + 5 H 2 O C H 3 N O + C 2 H 4 O 2 + 0.5 C 4 H 8 O 2 + 2 N H 3 + C O 2 + 0.5 O 2
C 6 H 14 N 4 O + 6 H 2 O 2 C 2 H 4 O 2 + 4 N H 3 + 2 C O 2 + 3 H 2
C 6 H 14 N 4 O + 4 H 2 O 0.5 C 2 H 4 O 2 + 0.5 C 3 H 6 O 2 + 0.5 C 5 H 10 O 2 + 4 N H 3 + C O 2 + 0.5 O 2
C 5 H 11 N O 2 S + 2 H 2 O C 3 H 6 O 2 + C O 2 + N H 3 + H 2 + C H 4 S
C 3 H 7 N O 3 + H 2 O C 2 H 4 O 2 + C O 2 + N H 3 + H 2
C 4 H 7 N O 4 + 2 H 2 O C 2 H 4 O 2 + 2 C O 2 + N H 3 + 2 H 2
C 5 H 9 N O 4 + H 2 O C 2 H 4 O 2 + 0.5 C 4 H 8 O 2 + C O 2 + N H 3
C 6 H 14 N 2 O 2 + 2 H 2 O C 2 H 4 O 2 + C 4 H 8 O 2 + 2 N H 3
C 6 H 13 N O 2 + 2 H 2 O C 5 H 10 O 2 + C O 2 + N H 3 + H 2
C 5 H 11 N O 2 + 2 H 2 O C 4 H 8 O 2 + C O 2 + N H 3 + 2 H 2
C 9 H 11 N O 2 + 2 H 2 O C 6 H 6 + C 2 H 4 O 2 + C O 2 + N H 3 + H 2
C 9 H 11 N O 3 + 2 H 2 O C 6 H 6 O + C 2 H 4 O 2 + C O 2 + N H 3 + H 2
C 11 H 12 N 2 O 2 + 2 H 2 O C 8 H 7 N + C 2 H 4 O 2 + C O 2 + N H 3 + H 2
C 3 H 7 N O 2 + 2 H 2 O C 4 H 8 O 2 + C O 2 + N H 3 + 2 H 2
C 3 H 6 N O 2 S + 2 H 2 O C 2 H 4 O 2 + C O 2 + N H 3 + 0.5 H 2 + H 2 S
C 5 H 9 N O 2 + 2 H 2 O 0.5 C 2 H 4 O 2 + 0.5 C 3 H 6 O 2 + 0.5 C 5 H 10 O 2 + N H 3 + 0.5 O 2
As in the simulation by Rajendran et al. [19], thermophilic conditions (55 °C) were considered to simulate the AD of amino acids. The hydrolysis of all amino acids followed the first-order reaction, with the kinetic constant (s−1) described in Equation (23) as function of the temperature (K) [19]:
k = 1.2753 · 10 6 · T 328.15 · e 1.41437 · 10 4 8.3145 · 1 T 1 328.15
The subsequent methanogenic stage [26] was also included as part of the anaerobic fermentation of all amino acids by considering the stoichiometry of Equations (24) and (25) and the first-order kinetic constant (s−1) following Equation (26) with the temperature in K [19]. Equation (25) was only considered if there was production of hydrogen in the previous acetogenic stage of degradation of amino acids. The modelling of the fermentation was confirmed by monitoring a constant value for Henry’s parameter of each volatile compound.
C 2 H 4 O 2 + 0.022 N H 3 0.022 C 5 H 7 N O 2 + 0.945 C H 4 + 0.066 H 2 O + 0.945 C O 2
14.4976 H 2 + 3.8334 C O 2 + 0.0836 N H 3 0.0836 C 5 H 7 N O 2 + 3.4154 C H 4 + 7.4996 H 2 O
k = 2.394 · 10 7 · T 328.15
Finally, a comprehensive model was developed to confirm the synthesis of NH4HCO3 with particular types of feedstocks for AD. The model included the stages of amino acid fermentation and extraction of NH4HCO3 for stabilization of the resulting anaerobic digestate (Figure 1). The process engineering software employed to develop the model allows consideration of a single stream with liquid and gas phases coming out of the fermenter. This concept is representative of real conditions when treating fresh anaerobic digestate saturated with biogas. The titrations of amino acid digestates were investigated by adding NaOH or HCl before the flash distillation, with the purpose of tuning the ratio of NH4+ to HCO3 in the distillate. The equilibrium-driven reactions that were considered for the modelling of the multiphase system NH3-CO2-H2O are shown in Table 1. A discussion is offered on which other parameters would need to be considered, in addition to the molar ratio of inorganic nitrogen (NH4++NH3+NH2COO) to inorganic carbon (CO2+HCO3+CO32−+NH2COO) of the anaerobic digestate, to facilitate the stabilization of this organic material by means of isolating the NH4HCO3. The 3 streams coming out of this synergistic process (Figure 1) are the upgraded biogas, the distillate (i.e., saturated NH4HCO3 aqueous solution), and the stabilized digestate.

3. Results

3.1. Preliminary Validation of the Aspen Plus® v12 ELECNRTL Methodology

Figure 2a shows that the results of the simulation follow the trends of the experimental data of Goppert and Maurer (1988), which were reported by Darde [27] in Figures 5–12 and Figures 5–13. The greatest volatility of CO2 corresponds to the greater partial pressure (at least two orders of magnitude greater) than that exerted by NH3 for any of the compositions of the anaerobic digestate investigated at the bubble point, as shown in Figure 2a. The chemistry of this blend also plays a crucial role in determining the volatility of these compounds, as partial pressure of the CO2 started to increase at a greater rate when the moles of this compound in the anaerobic digestate were greater than the moles of NH3 (Figure 2a), which was set to 0.6 mol/kg H2O for the whole test to comply with the experimental data available in Figures 5–12 and Figures 5–13 of Darde [27]. Typical concentrations of CO2 and NH3 in the anaerobic digestate are around 0.12 mol NH3/kg H2O and 0.07 mol CO2/kg H2O [22], which are milder concentrations than those tested by Darde et al. [28] for the development of a carbon capture process. However, given the wide scope of the ELECNRTL property method, the validation could be performed at the lower end of the concentration investigated by Darde et al. [28]. Figure 2b shows the calibration carried out with a concentration of 0.13 mol NH3/kg H2O with the experimental data of Pexton and Badger (1938), which is reported in Figures 2 and 3 of Darde et al. [28]. Figure 2c validates the precipitation of the NH4HCO3, which is less soluble than the NH4COONH2 and has similar solubility to NH4Cl and higher solubility than NaHCO3. Contrary to the explanation by Möller and Müller [8] on the formation of ammonium carbonate in the anaerobic digestate, Aspen Plus® v12 ELECNRTL does not consider the formation of this compound. Modelling the solubilities of NH4Cl and NaHCO3 was considered because the HCl and NaOH were tested as titrants of the anaerobic digestate to assist the flash distillation, tune the ratio of inorganic nitrogen to inorganic carbon in the distillate, and promote the precipitation of NH4HCO3. Therefore, NH4Cl and NaHCO3 might precipitate in the residual stabilized digestate and they are not expected in the distillate despite having solubility similar to or lower than NH4HCO3. The big difference in the solubility of NH4HCO3 modelled above 60 °C with regard to the experimental data available in the literature [29,30] is because this compound is not very stable and easily undergoes decomposition [31]. Figure 2d shows the modelling of the titration of the manure digestate resulting from the process described by Rajendran et al. [19] and considering some of the alkaline elements identified in the comprehensive characterization of various anaerobic digestates performed by Akhiar et al. [22]: NaHCO3, CaCl2, NaCl, and KHCO3 (Table A1). The validation of the simulation of the effect of HCl and NaOH on the proposed anaerobic digestate was achieved by comparison with experimental data of titrations available in the literature, particularly the study by Vandré and Clemens [32] of raw animal slurry and the previous work of Moure Abelenda et al. [23] with agrowaste digestate and food waste digestate. The results showed that the amount of CO2 and carbonates in the anaerobic digestate was responsible for the OH alkalinity at pH > 10. The content of ammonia was found to be the main cause of the partial (P) alkalinity and the total (M) alkalinity. This means that the volatile fatty acids (i.e., acetic acid and propionic acid) and other components (e.g., hydrogen sulfide; Table A1) previously reported with a role in regulating the pH of the anaerobic digestate [33] did not have a significant buffer effect in the present model. As can be seen in Figure A1, simply tuning of the ratio CO2 to NH3 in the digestate affects the pH, which shows the how the pH depends on the composition of the anaerobic digestates and the remaining stabilized digestates (Figure 1) after the flash separation indicated in Figure 2b.

3.2. Optimization of the Conditions of the Flash Distillation to Produce NH4HCO3

In the initial development stage of the flash distillation process for stabilization of anaerobic digestate and manufacturing of NH4HCO3, the target processing capacity was set at 1 t per h (i.e., proposed organic slurry with a composition of 55 kmol H2O/h, 0.1 kmol NH3/h, and 0.1 kmol CO2/h). The optimum temperatures for evaporation and condensation were investigated with this simplified composition of anaerobic digestate. Figure 3a shows the volatilization of NH3, CO2, and H2O as a function of the temperature. In order to appreciate significant release of CO2 from the anaerobic digestate, the temperature of the flash tank should be greater than 75 °C. There is not a big difference (i.e., around 0.2 °C) between the minimum temperature to obtain the maximum volatilization of NH3 and that of H2O (Figure 3a). However, it is this small difference that needs to be taken into account in the next stages of the design of the process to maximize the overall heat integration and profitability of the flash distillation process (Figure A2). Figure 3bpresents the concentrations of the different species in the distillate as a function of the condensation temperature. The condensation at a temperature below 70 °C maximizes the concentration of NH4+ and HCO3 (Figure 2b), which is necessary for the precipitation of NH4HCO3 when supersaturation is attained in the aqueous solution. In order to precipitate NH4HCO3 in the distillate cooled at 1 bar and 25 °C, the minimum temperature of the flash tank should be between 85 and 95 °C and the composition of the anaerobic digestate was found to be around 10 g NH3/L and 13 g CO2/L. This corresponds to a stream of anaerobic digestate fed to the flash distillation process at a rate of 55 kmol H2O/h, 0.6 kmol NH3/h, and 0.3 kmol CO2/h. Under these conditions, the maximum production of NH4HCO3 at a rate of 35.4 mol/h or 2.8 kg/h was found when the temperature of the flash tank was 95 °C (Figure A2).

3.3. Anaerobic Fermentation of Amino Acids

As this minimum composition of digestate to attain stabilization via manufacturing of NH4HCO3 is not in agreement with the typical composition of anaerobic digestate [22], the next step in defining the specifications of the flash process was to find a source of anaerobic digestate that provides a concentration of 10 g NH3/L and 13 g CO2/L. Since amino acids are ultimately responsible for the content of NH4+-N in the anaerobic digestate, the composition of the feedstock of AD was investigated by starting with these organic molecules. Although this is not a realistic approach because AD is a technology for handling complex matrices of organic waste materials, this investigation with process engineering software could give an idea of the type of residues that are more suitable for stabilizing the resulting anaerobic digestate with NH4HCO3 extraction. The concentration profile of all chemical species was elucidated for the fermentation of 18 amino acids (Figure A3), considering the stoichiometry and kinetics defined by Rajendran et al. [19], which are shown in Equations (1)–(26). In all cases, the feed of the anaerobic digester was considered to have 90 wt.% moisture [35] and the remaining 10 wt.% of the feedstock corresponded to the mass of amino acids. The discontinuous fermenters were operated under thermophilic conditions (i.e., 55 °C and 1 bar) for 1000 h (i.e., 42 days) in order to be able to observe the constant profiles of all chemical species, with the exception of glutamic acid that required a longer residence time (Figure A3h and Figure S8). For the present theoretical work, the hydrolysis reactions that would break down proteins into amino acids were omitted and the model only included the acidogenic, acetogenic, and methanogenic reactions. As the fermentation kinetics proposed by Rajendran et al. [19] were implemented, it was not necessary to define a highly active inoculum for the calculation block of the bioreactor to function properly. Most amino acids required at least 500 h in the bioreactor, with the exception of cysteine (Figure A3n) that was rapidly converted in less than 100 h. This simplified model corresponds with the first steps in elucidating the extent to which the feasibility of the NH4HCO3 stabilization of anaerobic digestate is limited by the type of feedstock for AD. The concentrations of inorganic nitrogen and inorganic carbon that were found in the anaerobic digestates of amino acids (Figure 4) were similar to those reported by Akhiar et al. [22].

3.4. Suitable Conditions for NH4HCO3-Stabilization of Anaerobic Digestate

As was expected according to the molecular formulas and stoichiometries of the amino acids’ fermentations, arginine provided the greatest amount of mineralized nitrogen (Figure 4), but this corresponded to only 0.6 g/L. The arginine digestate was also considered in the study by Drapanauskaite et al. [13]. This means that it would be necessary to consider at least a feedstock for AD with 3.5 times less water in relation to arginine for the development of the process. In this way, the overall process of fermentation and stabilization via synthesis of NH4HCO3 (Figure 1) was found to be feasible for arginine (C6H14N4O), glycine (C2H5NO2), and histidine (C6H9N3O2) only when the feedstocks of these amino acids were prepared with a moisture content lower than 90 wt.%. For example, NH4HCO3 production rates were 15.16, 3.00, and 1.82 kg/h when processing 1 tonne/h of digestates resulting from the individual AD of arginine, glycine, and histidine with 50 wt.% moisture. The moisture content of the digestate was estimated considering the initial composition of the feedstock to be fermented. The results of the titrations showed that the extent of stabilization of the anaerobic digestates coming from these amino acids can be greatly improved via acidification (in the case of arginine digestate; Figure 5a) and alkalization (for glycine and histidine; Figure 5b). The rate of addition of HCl was not enough to deplete the partial and total alkalinities of arginine, glycine, and histidine digestates (Figure 5a), as the pH never dropped below a level of 7 (Figure 2d). Similarly, the addition of NaOH was not enough to overcome the OH alkalinity (Figure 2d), except for the alkalization of histidine digestate which reached a pH above 9.5 (Figure 5b). The greatest NH4HCO3 extraction rates were 22.71 kg/h from arginine digestate (50 wt.% moisture) with 20 kg HCl/h (Figure 5a), 22.08 kg/h from glycine digestate (50 wt.% moisture) with 31 kg NaOH/h, and 34.18 kg/h from histidine digestate (50 wt.% moisture) with 44 kg NaOH/h (Figure 5b). The detrimental effect that acidification of glycine digestate and histidine digestate have on the production rate of NH4HCO3 should be noted (Figure 5a). Similarly, any addition of NaOH to the arginine digestate reduces the amount of NH4HCO3 that can be recovered. This is important to consider when elaborating a more complex digestate (i.e., coming from the blend of several amino acids). The maximum tolerances observed for the anaerobic digestates with 50 wt.% moisture were 27 kg NaOH/h applied to arginine digestate yielding 327.96 g NH4HCO3/h, 4 kg HCl/h applied to glycine digestate yielding 245.54 g NH4HCO3/h, and 2 kg HCl/h applied to histidine digestate yielding 146.34 g NH4HCO3/h. However, these trends changed when anaerobic digestates with greater moisture content were considered for the NH4HCO3 stabilization. The highest moisture content of amino acid digestates that was suitable for production of NH4HCO3 was dependent on the dose of acid and base. NaOH was a more effective titrant than HCl in the case of arginine digestate (>50 wt.% moisture), and HCl was a more effective titrant than NaOH for cysteine and histidine digestates (>50 wt.% moisture). The models developed in Aspen Plus® v12 ELECNRTL show the feasibility of (a) extraction of 142.30 g NH4HCO3/h from arginine digestate (62 wt.% moisture) by adding a dose of 1 kg NaOH/h, (b) extraction of 23.16 g NH4HCO3/h from arginine digestate (65 wt.% moisture) by adding a dose of 14 kg HCl/h, (c) extraction of 21.94 g NH4HCO3/h from glycine digestate (82 wt.% moisture) by adding a dose of 26 kg NaOH/h, (d) extraction of 469.01 g NH4HCO3/h from glycine digestate (53 wt.% moisture) by adding a dose of 1 kg HCl/h, (e) extraction of 72.70 g NH4HCO3/h from histidine digestate (81 wt.% moisture) by adding a dose of 34 kg NaOH/h, and (f) extraction of 109.21 g NH4HCO3/h from histidine digestate (51 wt.% moisture) by adding a dose of 1 kg HCl/h.

4. Discussion

The present study questions the reliability of measurements of nitrogen in anaerobic digestate [22,36,37], since stoichiometric calculations show that the nitrogen content is expected to be lower than 0.63 g/L when moisture is 90 wt.% (Figure A3). Modeling of AD resulted in almost the complete consumption of amino acids by the end of the 42 days of residence time (Figure A3), and this could be regarded as a very favorable scenario for the production of white ammonia [38]. However, the content of organic nitrogen in anaerobic digestate is never less than 30% of the total nitrogen [22]. Still considering all the conversion of organic nitrogen to inorganic forms, the amino acid digestate with 90 wt.% moisture was found not to be enough for stabilization via synthesis of NH4HCO3. It was necessary to reduce the moisture content of the feedstock of AD to 50 wt.% to enable the synthesis of NH4HCO3 from arginine digestate, glycine digestate, and histidine digestate. The fermentation of alanine (C3H7NO2; Figure A3o) and that of glutamine (C5H10N2O3; Figure A3r) also provided anaerobic digestates (50 wt.% moisture) with sufficient concentration of inorganic nitrogen and inorganic carbon (Figure 4), but the manufacturing of NH4HCO3 was not possible in these cases. The threshold values 0.02 mol N/L and 0.005 mol C/L, which were established based on the profile of glycine (Figure 4), explain why NH4HCO3 valorization was not attained with proline (C5H9NO2) and lysine (C6H14N2O2), despite their anaerobic digestates having the greatest inorganic nitrogen to inorganic carbon ratio. The inorganic forms of nitrogen are more readily available for plants, since these compounds do not need to be metabolized by the microbes in the rhizosphere, unlike organic nitrogen. These inorganic forms are also more prone to be lost via leaching and volatilization, hence the digestate is less stable and does not behave as controlled-release fertilizer. Traditionally, acidification has been used to prevent ammonia emissions from organic manure and slurry during storage and land application, because it reduces the pH and the NH3 can be kept in the aqueous solution as NH4+ [39]. However, in the approach of stabilizing the anaerobic digestate by NH4HCO3 extraction, the only purpose of using acids or alkalis is to promote the formation of a supersaturated distillate from where the crystals of the chemical grade fertilizer can be easily harvested. Hence, the doses of these endogenous agents to tune the pH of the anaerobic digestate need to be optimized accordingly, as long as NH4HCO3 is isolated.
A difference between the alanine digestate and glutamine digestate and the arginine digestate, glycine digestate, and histidine digestate is the presence of oxygen among the volatile compounds (Figure 6). Looking at the volatility of these gases, the use of the components of the residual biogas as stripping agents is appropriate because the volatility of H2 (129.87∙103 Pa·m3·mol−1) and O2 (76.92∙103 Pa·m3·mol−1) is greater than that of NH3 (1.69 Pa·m3·mol−1) and CO2 (3.03·103 Pa·m3·mol−1). The effect of these endogenous stripping agents could be the reason that the manufacturing of NH4HCO3 was possible with arginine, glycine, and histidine digestates, even when these had lower concentrations than 0.5 mol NH3/L and 0.3 mol CO2/L (Figure A2). The most intuitive reason for the lack of formation of NH4HCO3 in the distillate of the alanine and glutamine digestates (50 wt.% moisture) could be the low flowrate of NH3 in the stream of volatiles leaving the top of the flash tank at 95 °C (0.06 kmol NH3/h; Figure 6a). From a broader perspective, there are resemblances among the H2O and NH3 trends of the streams of volatile elements leaving the top of the flash tank during the processing of the five untreated amino acid digestates with 50% moisture (Figure 6a). Together with the pH of the digestate, this could be an explanation for why the volatilization of NH3 was the greatest in the arginine digestate (Figure 6a) and more NH4+ left the bottom of the flash tank when processing glycine, histidine, and glutamine digestates (Figure 6b). The pHs that were found in the stabilized digestates (50 wt.% moisture) leaving the bottom of the flash tank (Figure 1) were: 7.98 ± 0.52 (arginine); 7.53 ± 0.65 (glycine); 7.61 ± 0.59 (histidine); 7.12 ± 0.23 (alanine); and 7.14 ± 1.42 (glutamine).
According to Ukwuani and Tao [40], at the high pH employed for NH3 stripping, H2S and VFAs are largely dissociated in the aqueous phase and render little volatilization. This could explain the fact that Ukwuani and Tao [40] did not find acetic acid in the sulfuric acid solution upon absorption of the stripped ammonia under vacuum pressure at different boiling-point temperatures. However, other volatile organic compounds (VOCs) can end up in the distillate stream depending on the operating conditions. For example, working at low pressures (i.e., under vacuum conditions) contributes more than operating at high temperatures to increasing emissions of VOCs [40]. Ukwuani and Tao [40] reported cyclohexene, 4-methylphenol, 4-ethylphenol, trichloromethane, and (p-hydroxyphenyl)-phosphoric acid as the most common VOCs in the acid NH3 absorbent solution. The analysis of volatility that Ukwuani and Tao [40] carried out was based primarily on the concentration of these compounds in the absorbent solution at the different boiling points of the anaerobic digestate (ranging from 50 to 100 °C) under vacuum conditions, and secondly on the vapor pressure of the compound at 25 °C. Only for cyclohexene and chloroform are Henry’s law volatility constants greater than that of ammonia. It is important to highlight that Henry’s volatility constants are often reported as the ratio of vapor pressure and aqueous solubility [15]. Without considering the much greater solubility of NH3 in the aqueous solution, since the vapor pressure of NH3 (1002 kPa at 25 °C) is much greater than that of cyclohexane and chloroform (12 and 26 kPa, respectively), the VOC mass transfer is much slower. Cyclohexene (3.45·103 Pa·m3·mol−1) has a volatility even greater than that of carbon dioxide but lower than that of methane. Ukwuani and Tao [40] explained the presence of (p-hydroxyphenyl)-phosphoric acid in the absorbent solution by the excessive foam formation in the anaerobic digestate at a pH 9 in such a way that the foam reached the sulfuric acid solution. This was the reason that Drapanauskaite et al. [13] used defoaming agents based on silicon for the operation of distillation and stripping processes. Hence, in addition to the titrant, the need for an antifoaming agent needs to be assessed experimentally [35,41,42,43,44]. Alternatively, the use of exogenous stripping agents, such as nitrogen (156.25∙103 Pa·m3·mol−1) of air, which has even greater volatility than oxygen, is interesting but makes more difficult the subsequent upgrading of the biogas [45], as this gaseous stream becomes diluted. Ideally, the synthesis of NH4HCO3 will be coupled with biogas upgrading [46], but the purity of the crystals according to the specifications of the chemical fertilizers needs to be confirmed [40]. The kinetic reactions detailed in Table 2, which were proposed by AspenTech [47] to develop a rate-based model of CO2 capture process with NH3, could also be implemented in the present model to enhance the predictions of speciation in the NH3-CO2-H2O system.

5. Conclusions

The present study confirms the suitability of the conditions of the flash distillation (95 °C at 1 bar) for extracting NH4HCO3 from anaerobic digestates produced by the fermentation of arginine, glycine, and histidine. The use of HCl and NaOH was found necessary to maximize the stabilization of anaerobic digestates, although the rates of application of these titrants need to be further assessed from an economic point of view as well. This investigation elucidated an important role carried out by the most volatile compounds of biogas in the process of stabilization of anaerobic digestate. Therefore, it is recommended to carry out NH4HCO3 synthesis with anaerobic digestates saturated in biogas to maximize the endogenous stripping effect during the flash distillation. This process needs to be performed at the beginning of the storage of anerobic digestate to minimize the loss of the residual biogas.

Supplementary Materials

The following supporting information can be downloaded at: https://www.mdpi.com/article/10.3390/fermentation9080750/s1, Figure S1: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of glycine; Figure S2: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of threonine; Figure S3: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of arginine; Figure S4: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of proline; Figure S5: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of methionine; Figure S6: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of serine; Figure S7: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of aspartic acid; Figure S8: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of glutamic acid; Figure S9: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of lysine; Figure S10: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of leucine; Figure S11: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of valine; Figure S12: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of phenylalanine; Figure S13: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of tyrosine; Figure S14: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of cysteine; Figure S15: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of alanine; Figure S16: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of histidine; Figure S17: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of tryptophan; Figure S18: Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of glutamine. The models of titration, anaerobic digestion, and subsequent flash distillation process for amino acids can be found at: https://zenodo.org/record/7738947 (accessed on 29 July 2023).

Author Contributions

Conceptualization, A.M.A.; methodology, A.M.A.; software, A.M.A. and F.A.; validation, A.M.A.; formal analysis, A.M.A.; investigation, A.M.A.; resources, A.M.A. and F.A.; data curation, A.M.A. and F.A.; writing—original draft preparation, A.M.A.; writing—review and editing, A.M.A. and F.A.; visualization, A.M.A.; supervision, G.A. and F.A.; project administration, A.M.A. and F.A.; funding acquisition, A.M.A. and F.A. All authors have read and agreed to the published version of the manuscript.

Funding

This research was funded by Doctoral Prize of the Engineering and Physical Sciences Research Council (EPSRC) of the United Kingdom, award reference number 1945857.

Institutional Review Board Statement

Not applicable.

Informed Consent Statement

Not applicable.

Data Availability Statement

Research data are publicly available as Aspen Plus® models hosted by ZENODO [48].

Conflicts of Interest

The authors declare no conflict of interest. The funders had no role in the design of the study, in the collection, analyses, or interpretation of data, in the writing of the manuscript, or in the decision to publish the results.

Abbreviations

ABC, ammonium bicarbonate process; AD, anaerobic digestion; ELECNRTL, electrolyte non-random two-liquid; NH4+-N, ammoniacal nitrogen; VOCs, volatile organic compounds.

Appendix A

Table A1. List of components [19,22] considered for the simulation of the titration of the digestate in Aspen Pus v12, following the experimental procedure of Moure Abelenda et al. [23].
Table A1. List of components [19,22] considered for the simulation of the titration of the digestate in Aspen Pus v12, following the experimental procedure of Moure Abelenda et al. [23].
Component NameAliasCAS Numbermol/L
WATERH2O7732-18-545.69365
CARBON-DIOXIDECO2124-38-90.013835
AMMONIAH3N7664-41-70.100484
HYDROGEN-SULFIDEH2S7783-06-40.001921
ACETIC-ACIDC2H4O2-164-19-70.117655
GLYCEROLC3H8O356-81-50.000788
OLEIC-ACIDC18H34O2112-80-10.001519
DEXTROSEC6H12O650-99-70.119788
PROPIONIC-ACIDC3H6O2-179-09-40.000969
ETHYL-CYANOACETATEC5H7NO2105-56-64.19E-05
DL-ALANINEC3H7NO2-N9302-72-70.000452
ARGININEC6H14N4O2-N27004-12-80.000433
DL-ASPARTIC-ACIDC4H7NO4-N4617-45-80.000462
L-CYSTEINEC3H7NO2S-N152-90-40.000645
DL-GLUTAMIC-ACIDC5H9NO4-N5617-65-20.000712
GLYCINEC2H5NO2-D156-40-60.002407
L-ISOLEUCINEC6H13NO2-N373-32-50.000448
L-LEUCINEC6H13NO2-N261-90-50.000674
L-PHENYLALANINEC9H11NO263-91-20.000347
DL-PROLINEC5H9NO2-N9609-36-90.001069
DL-SERINEC3H7NO3-N5302-84-10.001656
C4H9NO3-N5C4H9NO3-N572-19-50.000452
C5H11NO2-N17C5H11NO2-N17516-06-30.000712
GLUTARIC-ACIDC5H8O4110-94-10.037695
HYDROGENH21333-74-01.55E-06
METHANECH474-82-80.000238
MALTOSEC12H22O11-N269-79-40.050679
TRIOLEINC57H104O6122-32-75.62E-05
TRIPALMITINC51H98O6555-44-26.18E-05
1-HEXADECANOLC16H34O36653-82-46.86E-08
2-OLEODIPALMITINC53H100O6-N12190-25-26.18E-05
TRILINOLENINC57H92O614465-68-08.4E-05
BETA-D-XYLOPYRANOSEC5H10O5-D32460-44-80.009424
LINOLEIC-ACIDC18H32O260-33-30.000756
ETHANOLC2H6O-264-17-50.13388
SODIUM-BICARBONATENAHCO3144-55-80.044112
CALCIUM-CHLORIDECACL210043-52-40.002876
SODIUM-CHLORIDENACL7647-14-50.003601
POTASSIUM-BICARBONATEKHCO3298-14-60.007789
Figure A1. Dependence of the pH on the composition of the anaerobic digestates and the remaining stabilized digestates (Figure 1) obtained after the flash separations shown in Figure 2b.
Figure A1. Dependence of the pH on the composition of the anaerobic digestates and the remaining stabilized digestates (Figure 1) obtained after the flash separations shown in Figure 2b.
Fermentation 09 00750 g0a1
Figure A2. Optimization of the temperature of the flash tank at atmospheric pressure for the production of NH4HCO3: (a) 94.2 °C, (b) 94.4 °C, (c) 94.6 °C, (d) 94.8 °C, (e) 95.0 °C, (f) 95.2 °C, (g) 95.4 °C, and (h) 95.6 °C. The flowrates of NH3 (0.5 to 0.6 kmol/h or 8 to 10 g/L) and CO2 (0.3 to 0.6 kmol/h or 13 to 26 g/L) along with the 55 kmol/h of H2O (or 990 kg/h), which is the main component of anaerobic digestate, were also considered as independent variables to maximize the production of NH4HCO3.
Figure A2. Optimization of the temperature of the flash tank at atmospheric pressure for the production of NH4HCO3: (a) 94.2 °C, (b) 94.4 °C, (c) 94.6 °C, (d) 94.8 °C, (e) 95.0 °C, (f) 95.2 °C, (g) 95.4 °C, and (h) 95.6 °C. The flowrates of NH3 (0.5 to 0.6 kmol/h or 8 to 10 g/L) and CO2 (0.3 to 0.6 kmol/h or 13 to 26 g/L) along with the 55 kmol/h of H2O (or 990 kg/h), which is the main component of anaerobic digestate, were also considered as independent variables to maximize the production of NH4HCO3.
Fermentation 09 00750 g0a2
Figure A3. Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of the amino acids: (a) glycine, (b) threonine, (c) arginine, (d) proline, (e) methionine, (f) serine, (g) aspartic acid, (h) glutamic acid, (i) lysine, (j) leucine, (k) valine, (l) phenylalanine, (m) tyrosine, (n) cysteine, (o) alanine, (p) histidine, (q) tryptophan, and (r) glutamine. The feedstocks that were considered to perform these anaerobic digestions consisted of 90% moisture. The Supplementary Material shows all these Figures separately (Figures S1–S18).
Figure A3. Concentration profile of the species of inorganic nitrogen and inorganic carbon during the fermentation of the amino acids: (a) glycine, (b) threonine, (c) arginine, (d) proline, (e) methionine, (f) serine, (g) aspartic acid, (h) glutamic acid, (i) lysine, (j) leucine, (k) valine, (l) phenylalanine, (m) tyrosine, (n) cysteine, (o) alanine, (p) histidine, (q) tryptophan, and (r) glutamine. The feedstocks that were considered to perform these anaerobic digestions consisted of 90% moisture. The Supplementary Material shows all these Figures separately (Figures S1–S18).
Fermentation 09 00750 g0a3

References

  1. da Costa Gomez, C. Biogas as an energy option: An overview. In The Biogas Handbook: Science, Production and Applications, 1st ed.; Wellinger, A., Murphy, J.D., Baxter, D., Eds.; Woodhead Publishing Ltd.: Cambridge, UK, 2013; pp. 1–16. [Google Scholar]
  2. Patel, S.K.S.; Das, D.; Kim, S.C.; Cho, B.-K.; Kalia, V.C.; Lee, J.-K. Integrating strategies for sustainable conversion of waste biomass into dark-fermentative hydrogen and value-added products. Renew. Sustain. Energy Rev. 2021, 150, 111491. [Google Scholar] [CrossRef]
  3. Seadi, T.A.; Lukehurst, C. Quality Management of Digestate from Biogas Plants Used as Fertiliser; IEA Bioenergy, 2012; p. 40. Available online: http://www.iea-biogas.net/files/daten-redaktion/download/publi-task37/digestate_quality_web_new.pdf (accessed on 29 July 2023).
  4. Lukehurst, C.; Frost, P.; Seadi, T.A. Utilisation of Digestate from Biogas Plants as Biofertiliser; IEA Bioenergy, 2010; Available online: https://task37.ieabioenergy.com/wp-content/uploads/sites/32/2022/02/Digestate_Brochure_Revised_12-2010.pdf (accessed on 29 July 2023).
  5. Astals, S.; Martínez-Martorell, M.; Huete-Hernández, S.; Aguilar-Pozo, V.B.; Dosta, J.; Chimenos, J.M. Nitrogen recovery from pig slurry by struvite precipitation using a low-cost magnesium oxide. Sci. Total Environ. 2021, 768, 144284. [Google Scholar] [CrossRef] [PubMed]
  6. Drosg, B.; Fuchs, W.; Al Seadi, T.; Madsen, M.; Linke, B. Nutrient Recovery by Biogas Digestate Processing. Available online: https://task37.ieabioenergy.com/wp-content/uploads/sites/32/2022/02/NUTRIENT_RECOVERY_RZ_web2.pdf (accessed on 14 December 2021).
  7. Fuchs, W.; Drosg, B. Assessment of the state of the art of technologies for the processing of digestate residue from anaerobic digesters. Water Sci. Technol. 2013, 67, 1984–1993. [Google Scholar] [CrossRef]
  8. Moller, K.; Muller, T. Effects of anaerobic digestion on digestate nutrient availability and crop growth: A review. Eng. Life Sci. 2015, 12, 242–257. [Google Scholar] [CrossRef]
  9. Burke, D.A. Removal of Ammonia from Fermentation Effluent and Sequestration as Ammonium Bicarbonate and/or Carbonate. 12. 2010. Available online: https://patents.google.com/patent/US7811455B2/en (accessed on 29 July 2023).
  10. Burke, D.A. Reclaiming Ammonia from Anaerobic Digestate As A Profitable Product. Proc. Water Environ. Fed. 2015, 2015, 1–12. [Google Scholar] [CrossRef]
  11. Bassani, D.; Orentlicher, M.; Simon, M.M.; Pagano, S. Process to Recover Ammonium Bicarbonate from Wastewater. 2019. Available online: https://patents.google.com/patent/US10106447B2/en (accessed on 29 July 2023).
  12. Jamaludin, Z.; Rollings-Scattergood, S.; Lutes, K.; Vaneeckhaute, C. Evaluation of sustainable scrubbing agents for ammonia recovery from anaerobic digestate. Bioresour. Technol. 2018, 270, 596–602. [Google Scholar] [CrossRef]
  13. Drapanauskaite, D.; Handler, R.M.; Fox, N.; Baltrusaitis, J. Transformation of Liquid Digestate from the Solid-Separated Biogas Digestion Reactor Effluent into a Solid NH4HCO3 Fertilizer: Sustainable Process Engineering and Life Cycle Assessment. ACS Sustain. Chem. Eng. 2021, 9, 580–588. [Google Scholar] [CrossRef]
  14. Budzianowski, W.M. Benefits of biogas upgrading to biomethane by high-pressure reactive solvent scrubbing. Biofuels Bioprod. Biorefin. 2012, 6, 12–20. [Google Scholar] [CrossRef]
  15. Sander, R. Compilation of Henry’s law constants (version 4.0) for water as solvent. Atmos. Chem. Phys. 2015, 15, 4399–4981. [Google Scholar] [CrossRef]
  16. Walker, M.; Banks, C.; Heaven, S.; Frederickson, J. Residual Biogas Potential Test for Digestates; WRAP: Banbury, UK, 2010; Available online: https://www.ktbl.de/fileadmin/user_upload/Allgemeines/Download/Ringversuch-Biogas/Residual-Biogas-Potential.pdf (accessed on 29 July 2023).
  17. Saveyn, H.; Eder, P. End-of-Waste Criteria for Biodegradable Waste Subjected to Biological Treatment (Compost & Digestate): Technical Proposals. Available online: https://publications.jrc.ec.europa.eu/repository/handle/JRC87124 (accessed on 14 December 2021).
  18. WRAP. BSI PAS 110:2014 Specification for Whole Digestate, Separated Liquor and Separated Fibre Derived from the Anaerobic Digestion of Source-Segregated Biodegradable Materials. Available online: https://wrap.org.uk/sites/default/files/2021-03/PAS110_2014.pdf (accessed on 7 January 2022).
  19. Rajendran, K.; Kankanala, H.R.; Lundin, M.; Taherzadeh, M.J. A novel process simulation model (PSM) for anaerobic digestion using Aspen Plus. Bioresour. Technol. 2014, 168, 7–13. [Google Scholar] [CrossRef] [PubMed]
  20. Centorcelli, J.C.; Drapanauskaite, D.; Handler, R.M.; Baltrusaitis, J. Solar Steam Generation Integration into the Ammonium Bicarbonate Recovery from Liquid Biomass Digestate: Process Modeling and Life Cycle Assessment. ACS Sustain. Chem. Eng. 2021, 9, 15278–15286. [Google Scholar] [CrossRef]
  21. Centorcelli, J.C.; Luyben, W.L.; Romero, C.E.; Baltrusaitis, J. Dynamic Control of Liquid Biomass Digestate Distillation Combined with an Integrated Solar Concentrator Cycle for Sustainable Nitrogen Fertilizer Production. ACS Sustain. Chem. Eng. 2022, 10, 7409–7417. [Google Scholar] [CrossRef]
  22. Akhiar, A.; Battimelli, A.; Torrijos, M.; Carrere, H. Comprehensive characterization of the liquid fraction of digestates from full-scale anaerobic co-digestion. Waste Manag. 2017, 59, 118–128. [Google Scholar] [CrossRef] [PubMed]
  23. Moure Abelenda, A.; Semple, K.T.; Lag-brotons, A.J.; Herbert, B.M.J.; Aggidis, G.; Aiouache, F. Strategies for the production of a stable blended fertilizer of anaerobic digestates and wood ashes. Nat. Based Solut. 2022, 2, 10014. [Google Scholar] [CrossRef]
  24. Government, U.K. Annex 3: FETF 2023 Productivity and Slurry Eligible Items. 2023. Available online: https://www.gov.uk/government/publications/farming-equipment-and-technology-fund-fetf-2023/annex-3-fetf-2023-productivity-and-slurry-eligible-items (accessed on 29 July 2023).
  25. García-Ochoa, F.; Santos, V.E.; Naval, L.; Guardiola, E.; López, B. Kinetic model for anaerobic digestion of livestock manure. Enzym. Microb. Technol. 1999, 25, 55–60. [Google Scholar] [CrossRef]
  26. Canu, P.; Pagin, M. Biogas upgrading by 2-steps methanation of its CO2—Thermodynamics analysis. J. CO2 Util. 2022, 63, 102123. [Google Scholar] [CrossRef]
  27. Darde, V. CO2 Capture Using Aqueous Ammonia. 2011. Available online: https://www.cere.dtu.dk/-/media/centre/cere/publications/phd-thesis/2011/victor_darde_phd.pdf?la=da&hash=8A67D4D04AFF063B772D6A90CC6D88B9BEBAEABD (accessed on 29 July 2023).
  28. Darde, V.; van Well, W.J.M.; Stenby, E.H.; Thomsen, K. Modeling of Carbon Dioxide Absorption by Aqueous Ammonia Solutions Using the Extended UNIQUAC Model. Ind. Eng. Chem. Res. 2010, 49, 12663–12674. [Google Scholar] [CrossRef]
  29. Mullin, J.W. Crystallization, 4th ed.; Butterworth-Heinemann: Oxford, UK; Boston, MA, USA, 2001; Table A.4. [Google Scholar]
  30. Haynes, W.M. CRC Handbook of Chemistry and Physics: A Ready-Reference Book of Chemical and Physical Data, 91st ed.; CRC Press: Boca Raton, FL, USA, 2010. [Google Scholar]
  31. Brondi, M.; Eisa, M.; Bortoletto-Santos, R.; Drapanauskaite, D.; Reddington, T.; Williams, C.; Ribeiro, C.; Baltrusaitis, J. Recovering, Stabilizing, and Reusing Nitrogen and Carbon from Nutrient-Containing Liquid Waste as Ammonium Carbonate Fertilizer. Agriculture 2023, 13, 909. [Google Scholar] [CrossRef]
  32. Vandré, R.; Clemens, J. Studies on the relationship between slurry pH, volatilization processes and the influence of acidifying additives. Nutr. Cycl. Agroecosyst. 1996, 47, 157–165. [Google Scholar] [CrossRef]
  33. Mu, Z.X.; He, C.S.; Jiang, J.K.; Zhang, J.; Yang, H.Y.; Mu, Y. A modified two-point titration method for the determination of volatile fatty acids in anaerobic systems. Chemosphere 2018, 204, 251–256. [Google Scholar] [CrossRef]
  34. Green, D.W.; Perry, R.H. Perry’s Chemical Engineers’ Handbook, 8th ed.; McGraw-Hill: New York, NY, USA; London, UK, 2008; pp. 140–145. [Google Scholar]
  35. Limoli, A.; Langone, M.; Andreottola, G. Ammonia removal from raw manure digestate by means of a turbulent mixing stripping process. J. Environ. Manag. 2016, 176, 1–10. [Google Scholar] [CrossRef]
  36. Astals, S.; Nolla-Ardèvol, V.; Mata-Alvarez, J. Anaerobic co-digestion of pig manure and crude glycerol at mesophilic conditions: Biogas and digestate. Bioresour. Technol. 2012, 110, 63–70. [Google Scholar] [CrossRef]
  37. Astals, S.; Nolla-Ardèvol, V.; Mata-Alvarez, J. Thermophilic co-digestion of pig manure and crude glycerol: Process performance and digestate stability. J. Biotechnol. 2013, 166, 97–104. [Google Scholar] [CrossRef]
  38. European Sustainable Phosphorus Platform. 1st White Ammonia Research Meeting (WARM)—7th June 2023. 2023. Available online: https://www.phosphorusplatform.eu/activities/conference/n-recovery (accessed on 29 July 2023).
  39. Fangueiro, D.; Hjorth, M.; Gioelli, F. Acidification of animal slurry—A review. J. Environ. Manag. 2015, 149, 46–56. [Google Scholar] [CrossRef] [PubMed]
  40. Ukwuani, A.T.; Tao, W. Developing a vacuum thermal stripping—Acid absorption process for ammonia recovery from anaerobic digester effluent. Water Res. 2016, 106, 108–115. [Google Scholar] [CrossRef]
  41. Martín-Hernández, E.; Sampat, A.M.; Zavala, V.M.; Martín, M. Optimal integrated facility for waste processing. Chem. Eng. Res. Des. 2018, 131, 160–182. [Google Scholar] [CrossRef]
  42. Morey, L.; Fernández, B.; Tey, L.; Biel, C.; Robles-Aguilar, A.; Meers, E.; Soler, J.; Porta, R.; Cots, M.; Riau, V. Acidification and solar drying of manure-based digestate to produce improved fertilizing products. J. Environ. Manag. 2023, 336, 117664. [Google Scholar] [CrossRef]
  43. Moure Abelenda, A.; Semple, K.T.; Aggidis, G.; Aiouache, F. Dataset on the solid-liquid separation of anaerobic digestate by means of wood ash-based treatment. Data Brief 2022, 44, 108536. [Google Scholar] [CrossRef]
  44. Meixner, K.; Fuchs, W.; Valkova, T.; Svardal, K.; Loderer, C.; Neureiter, M.; Bochmann, G.; Drosg, B. Effect of precipitating agents on centrifugation and ultrafiltration performance of thin stillage digestate. Sep. Purif. Technol. 2015, 145, 154–160. [Google Scholar] [CrossRef]
  45. Baena-Moreno, F.M.; Saché, E.L.; Hurd Price, C.A.; Reina, T.R.; Navarrete, B. From biogas upgrading to CO2 utilization and waste recycling: A novel circular economy approach. J. CO2 Util. 2021, 47, 101496. [Google Scholar] [CrossRef]
  46. Moure Abelenda, A.; Ali, A.; Semple, K.T.; Aiouache, F. Aspen Plus® Process Simulation Model of the Biomass Ash-Based Treatment of Anaerobic Digestate for Production of Fertilizer and Upgradation of Biogas. Energies 2023, 16, 3039. [Google Scholar] [CrossRef]
  47. Aspen Technology. Rate-Based Model of the CO2 Capture Process by NH3 Using Aspen Plus Aspen Plus; Aspen Technology: Bedford, MA, USA, 2008. [Google Scholar]
  48. Moure Abelenda, A. Aspen Plus Models of the Flash Distillation Process for Stabilization of Anaerobic Digestate and Synthesis of Ammonium Bicarbonate. 2023. Available online: https://www.zenodo.org/record/7738947 (accessed on 29 July 2023).
Figure 1. Process flow diagram with capacity to handle 1 t of feedstock (blend of amino acid and water) per h, to evaluate the feasibility of producing NH4HCO3 from different types of anaerobic digestates.
Figure 1. Process flow diagram with capacity to handle 1 t of feedstock (blend of amino acid and water) per h, to evaluate the feasibility of producing NH4HCO3 from different types of anaerobic digestates.
Fermentation 09 00750 g001
Figure 2. Validation of the modelling of the system NH3-CO2-H2O with Aspen Plus® v12. (a) Comparison of the partial pressures of CO2 and NH3 calculated with ELECNRT property method and the experimental data available in Figures 5–12 and Figures 5–13 of Darde [27]. (b) Validation of the flash distillation by comparing the results of the simulation with the experimental data available in Figures 2 and 3 of Darde et al. [28]. (c) Validation of the solid formation by comparing the results of the simulation with the experimental data reported by Mullin [29], Green and Perry [34], and Haynes [29]. (d) Validation of the processing of manure digestate [19,22] with the addition of NaOH and HCl by comparison with the empirical titration of agrowaste digestate, food waste digestate [23], and animal slurry [32].
Figure 2. Validation of the modelling of the system NH3-CO2-H2O with Aspen Plus® v12. (a) Comparison of the partial pressures of CO2 and NH3 calculated with ELECNRT property method and the experimental data available in Figures 5–12 and Figures 5–13 of Darde [27]. (b) Validation of the flash distillation by comparing the results of the simulation with the experimental data available in Figures 2 and 3 of Darde et al. [28]. (c) Validation of the solid formation by comparing the results of the simulation with the experimental data reported by Mullin [29], Green and Perry [34], and Haynes [29]. (d) Validation of the processing of manure digestate [19,22] with the addition of NaOH and HCl by comparison with the empirical titration of agrowaste digestate, food waste digestate [23], and animal slurry [32].
Fermentation 09 00750 g002
Figure 3. Optimization of the steps of evaporation and condensation that comprise the flash distillation process for stabilization of anaerobic digestate and isolation of NH4HCO3: (a) determination of the optimum flash-heating temperature to achieve a vapor stream with the greatest concentration of CO2 and NH3; (b) determination of the optimum condensation temperature to attain the maximum concentration of NH4+ and HCO3 in the distillate.
Figure 3. Optimization of the steps of evaporation and condensation that comprise the flash distillation process for stabilization of anaerobic digestate and isolation of NH4HCO3: (a) determination of the optimum flash-heating temperature to achieve a vapor stream with the greatest concentration of CO2 and NH3; (b) determination of the optimum condensation temperature to attain the maximum concentration of NH4+ and HCO3 in the distillate.
Fermentation 09 00750 g003
Figure 4. Inorganic nitrogen (NH4++NH3+NH2COO) to inorganic carbon (CO2+HCO3+CO32−+NH2COO) ratio in the anaerobic digestate that resulted from the fermentation of each of the 18 amino acids. The feed of each individual fermentation was composed of 90 wt.% moisture and 10 wt.% amino acid.
Figure 4. Inorganic nitrogen (NH4++NH3+NH2COO) to inorganic carbon (CO2+HCO3+CO32−+NH2COO) ratio in the anaerobic digestate that resulted from the fermentation of each of the 18 amino acids. The feed of each individual fermentation was composed of 90 wt.% moisture and 10 wt.% amino acid.
Fermentation 09 00750 g004
Figure 5. Optimization of the NH4HCO3 stabilization via addition of (a) HCl and (b) NaOH to enhance the flash distillation of amino acid digestates produced with a feedstock of 50 wt.% moisture. The square symbols represent the pH of the stabilized digestates that leave the bottom of the flash tank (Figure 1).
Figure 5. Optimization of the NH4HCO3 stabilization via addition of (a) HCl and (b) NaOH to enhance the flash distillation of amino acid digestates produced with a feedstock of 50 wt.% moisture. The square symbols represent the pH of the stabilized digestates that leave the bottom of the flash tank (Figure 1).
Fermentation 09 00750 g005
Figure 6. Flowrate of the most relevant chemical species for the manufacturing of NH4HCO3 leaving (a) the top and (b) the bottom of the flash distillation of five untreated amino acid digestates (50 wt.% moisture). The flowrate of water in the stabilized digestate was omitted to give a clear picture of the most relevant species of inorganic nitrogen and inorganic carbon. The flowrates of water in the stabilized digestates of arginine, glycine, histidine, alanine, and glutamine are 18.39, 24.78, 21.07, 23.79, and 24.21 kmol/h, respectively.
Figure 6. Flowrate of the most relevant chemical species for the manufacturing of NH4HCO3 leaving (a) the top and (b) the bottom of the flash distillation of five untreated amino acid digestates (50 wt.% moisture). The flowrate of water in the stabilized digestate was omitted to give a clear picture of the most relevant species of inorganic nitrogen and inorganic carbon. The flowrates of water in the stabilized digestates of arginine, glycine, histidine, alanine, and glutamine are 18.39, 24.78, 21.07, 23.79, and 24.21 kmol/h, respectively.
Fermentation 09 00750 g006
Table 1. Equilibrium-driven reactions for the system NH3-CO2-H2O proposed by the property method ELECNRTL of the electrolyte template of Aspen Plus® v12.
Table 1. Equilibrium-driven reactions for the system NH3-CO2-H2O proposed by the property method ELECNRTL of the electrolyte template of Aspen Plus® v12.
ln ( K e q ) = A + B T + C · ln ( T ) + D · T ABCD
2 H 2 O + C O 2 H C O 3 + H 3 O + 231.46542412092.09960936.7816010
H 2 O + H C O 3 C O 3 2 + H 3 O + 216.05044612431.70019535.4818990
N H 3 + H 2 O O H + N H 4 + 1.2565633335.6999511.4971−0.037057
N H 3 + H C O 3 H 2 O + N H 2 C O O 4.583437290000
N H 4 + + H C O 3 N H 4 H C O 3 554.81811522442.52929789.0064160.064732
N H 4 + + N H 2 C O O N H 4 C O O N H 2 4.289233000
Table 2. Kinetics of the NH3-CO2-H2O system defined by AspenTech [47].
Table 2. Kinetics of the NH3-CO2-H2O system defined by AspenTech [47].
K i n e t i c   F a c t o r = k · e E R · T k/(d−1)E/(cal/mol)
C O 2 + O H H C O 3 4.32·101313.249
H C O 3 C O 2 + O H 2.38·101729.451
N H 3 + C O 2 + H 2 O N H 2 C O O + H 3 O + 1.35·101111.585
N H 2 C O O + H 3 O + N H 3 + C O 2 + H 2 O 2.14·102117.203
Disclaimer/Publisher’s Note: The statements, opinions and data contained in all publications are solely those of the individual author(s) and contributor(s) and not of MDPI and/or the editor(s). MDPI and/or the editor(s) disclaim responsibility for any injury to people or property resulting from any ideas, methods, instructions or products referred to in the content.

Share and Cite

MDPI and ACS Style

Moure Abelenda, A.; Aggidis, G.; Aiouache, F. Modelling of Amino Acid Fermentations and Stabilization of Anaerobic Digestates by Extracting Ammonium Bicarbonate. Fermentation 2023, 9, 750. https://doi.org/10.3390/fermentation9080750

AMA Style

Moure Abelenda A, Aggidis G, Aiouache F. Modelling of Amino Acid Fermentations and Stabilization of Anaerobic Digestates by Extracting Ammonium Bicarbonate. Fermentation. 2023; 9(8):750. https://doi.org/10.3390/fermentation9080750

Chicago/Turabian Style

Moure Abelenda, Alejandro, George Aggidis, and Farid Aiouache. 2023. "Modelling of Amino Acid Fermentations and Stabilization of Anaerobic Digestates by Extracting Ammonium Bicarbonate" Fermentation 9, no. 8: 750. https://doi.org/10.3390/fermentation9080750

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop