Next Article in Journal
A Multi-Wavelength Raman Study of Some Oligothiophenes and Polythiophene
Previous Article in Journal
Measurement Precision and Thermal and Absorption Properties of Nanostructures in Aqueous Solutions by Transient and Steady-State Thermal-Lens Spectrometry
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Article

Additive Based on Synthetic Aluminosilicates for Dry Lime Construction Mixtures

by
Valentina Ivanovna Loganina
*,
Kristina Vladimirovna Zhegera
and
Maria Anatolyevna Svetalkina
Department “Quality Management and Technology of Construction Production”, Penza State University of Architecture and Construction, st.G. Titova, 28, 440028 Penza, Russia
*
Author to whom correspondence should be addressed.
Physchem 2023, 3(1), 198-209; https://doi.org/10.3390/physchem3010013
Submission received: 18 January 2023 / Revised: 3 March 2023 / Accepted: 13 March 2023 / Published: 15 March 2023

Abstract

:
The possibility of increasing the durability of coatings based on lime dry construction mix by introducing an additive containing synthetic aluminosilicates is substantiated. The regularities of the structure formation of the lime composite in the presence of an additive containing synthetic aluminosilicates, which additionally consists of a formation of calcium–sodium hydrosilicates and minerals of the zeolite group, an increase in the amount of chemically bound lime by 8.74%, are revealed. X-ray diffraction analysis and thermodynamic calculations have established that the mineralogical composition of the crystalline phase of the additive based on synthetic aluminosilicates is represented by thenardite, gibbsite, and the minerals of the zeolite group. It is shown that the content of the amorphous phase is 77.5%. It was found that the additive based on synthetic aluminosilicates is characterized by high activity, which is more than 350 mg/g. It was also found that the introduction of an additive based on synthetic aluminosilicates into the formulation of a lime dry mixture accelerates the curing of coatings and increases the compressive strength after 28 days of air-dry hardening by 1.9 times.

1. Introduction

The modern production of dry building mixtures is unthinkable without the use of modifying additives. Even though the main processes for the formation of the properties of mortars are determined by interactions in the “mineral binder—aggregate—water” system, the introduction of inorganic and organic modifying additives into such a system makes it possible to change almost all characteristics of the material.
As is known, lime binder hardens very slowly, which complicates the production of finishing works. To accelerate the hardening and increase the strength of lime composites, additives are introduced into the formulation. Zeolites are one of the common additives. Considering the locality of natural zeolite reserves and the heterogeneity of their composition and properties, the use of synthetic zeolites in lime compositions is proposed.
Zeolites are aqueous aluminosilicates of alkali and alkaline earth metals with an open-frame cavity structure. The crystalline three-dimensional framework consists of aluminum–silicon–oxygen [(Si,Al)O4] tetrahedra combined into simple, double, and more complex rings; moreover, each ring includes 4, 5, 6, 8, or more tetrahedra. Because some of the tetravalent silicon ions (Si+4) are replaced by trivalent aluminum ions (Al+3), this frame has a negative charge, compensated by the presence on the walls of the cavities of one- and two-tape cations of sodium, potassium, calcium, and magnesium, as well as, less often, barium, strontium, lithium, and other metals.
Total volume of cavities and channels connecting them in zeolites constitutes about 50% of the crystal volume, and the diameter of these channels’ crystal surface varies from 0.26 to 0.8 nm. Internal cavities and the channels connecting them are filled with molecules of the so-called “zeolitenoah” of water.
In general, the composition of zeolites can be expressed by the formula:
MxDy[Alx + 2ySizO2x + 4y + 2z] nH2O,
where M and D are mono- and divalent cations, respectively;
x + y is the sum of tetrahedra in a unit cell.
Synthetic zeolites can be obtained using the hydrothermal crystallization of alkaline aluminosilicate mixtures. There are several ways to obtain synthetic zeolites. In 1862, St. Clair Deville received a synthetic potassium phillipsite when heating silicate and potassium aluminate at 200 °C. Synthetic chabazite was obtained under similar conditions at temperatures up to 170 °C. In 1948, Professor R. Barrer began work on the synthesis of zeolites [1]. Breck D. et al. determined the conditions for obtaining basic zeolites general purpose type NaX and NaA [2,3]. One way to obtain zeolites is through the continuous hydrothermal crystallization of aluminosilicate [4]. There is also a method for obtaining zeolites of the NaX type [5]. This way consists of preparing solutions of sodium metasilicate and sodium aluminate, adding an amine-containing compound from the series triethanolamine, polyethylene polyamine, or phenylenediamine to solutions, and preparing a gel by mixing the resulting solutions. The gel is mixed with dimethyl sulfoxide, and hydrothermal crystallization is carried out at a temperature of 70–100 °C. In [6,7], the technology for preparing adsorbents includes the preparation of hydro reactive heterogeneous composition containing aluminum powder, sodium metasilicate, and water, and the interaction of the initial components. Another method for producing sodium aluminosilicate is known, which involves the interaction of a solution of sodium silicate and an aluminum salt in a mixture of water-immiscible tributyl phosphate [8,9].
In Russian patent 2476378 No., the NaY zeolite was prepared using an aqueous mixture of sodium oxide, silica, and alumina, containing 1–5.0 M phenylenediamine, then heating the mixture to a crystallization temperature, maintaining this temperature until the crystals and the separation of the crystals from the solution were achieved. The mole ratio of oxides in the mixture were Na2O/SiO2 1.6–2.2; SiO2/Al2O3 1.5–5; H2O/Na2O 70–150. The invention provides a faujasite structure zeolite—NaY with a ratio SiO2/Al2O3 higher than 3.1 and a crystal size of no less than 20 microns.
In conventional conditions, during hydrothermal preparation, NaY crystals with a size less than 1 micron, more often 0.1–0.3, are used. NaY crystals of this size are used for catalytic, sorption, and other areas of the oil refining and chemical industries [US3130007 patent (B1); Patent JP2001058816 (A), the IPC: S01V 39/24, publ. 06.03.2001; US6284218 (B1) Patent IPC: S01V 39/20, publ. 04.09.2001; Patent JP2008230886 (A), the IPC: B01J 29/08; S01V 39/02, publ. 02.10.2008].
Russian patent 2463108 discloses a method for producing aluminosilicate composition comprising from 40 to 75% by weight. Silicon oxide, the process of which comprises of (a) combining in a mixing zone water and aluminum sulfate to produce a mixture with a pH in the range from 1.5 to 6.5; (b) then, raising the pH of said mixture to a value in the range from 7.5 to 12 by adding sodium silicate to said mixture in said mixing zone, and (c) recovering a precipitate solid from said mixture in said mixing zone, wherein said precipitate solid comprises said aluminosilicate composition.
A method of producing a synthetic zeolite microsphere granule (A.S USSR №146285, 1968) includes spray drying an aqueous slurry of the crystalline zeolite to the binder addition (highly plastic clays and fine), taken in an amount of 10–35 wt.% of zeolite mass.
U.S. Patent No. 6872685 describes a composition of amorphous aluminosilicate, characterized surfactants bulk Si/Al ratio (SB ratio) in a range from 0.7 to 1.3 and containing less than 10% crystalline alumina phase. This amorphous aluminosilicate is obtained by mixing a silicate (sodium silicate) and an acid aluminum salt solution (aluminum sulfate) while maintaining the pH of the stirred solution less than 3, then by gradually adding a basic precipitant to the stirred solution to form a precipitated co-gel, which is then extracted, washed, and subjected to spray drying.
U.S. Patent No. 4988659 described aluminosilicate to gel and process for preparing such a gel. Co-gel was prepared by adding a silicate solution to an aqueous solution of the acid and acidic aluminum salt such as aluminum chloride or aluminum sulfate to form an acidified silica sol with a pH in the range from 1 to 4, further increasing the pH of the sol by adding a base, aging, and recovering the resulting sol to gel. The recovered co-gel can be further processed by using acid during excitation syneresis, followed by washing and then spray dried.
Despite a significant amount of research on methods obtaining synthetic zeolites, the issues of their application in the construction industry have not been fully covered. Meanwhile, the presence of amorphous aluminosilicate in the composition of synthetic zeolites creates prerequisites for their use in lime composites.
During the interaction of amorphous aluminosilicate with lime, the formation of calcium aluminosilicate and calcium hydrosilicates is possible, which will accelerate the curing and increase the strength of lime composites.
The purpose of the work is to develop technology for obtaining an additive based on synthetic aluminosilicates and evaluate the effectiveness of its use in dry lime mortars.

2. Materials and Methods

The following materials were used to prepare the supplement: technical aluminum sulfate, liquid sodium glass (GOST 13078-2021).
Solutions of sodium water glass and aluminum sulfate of various densities were prepared, after which the water glass solution was added to the aluminum sulfate solution.
The precipitate was thoroughly washed and filtered on White Tape filter paper. Then, it was placed in an oven and dried at a temperature of 100–110 °C to a constant weight, after which it was ground into powder.
To study the regularities of the influence of additives based on synthetic aluminosilicates on the properties of lime composites, samples were prepared on the fluffy lime of the 1st grade with an activity of 84.4%. For comparison, additives were used—diatomite, meta kaolinite. The content of additives based on synthetic aluminosilicates, diatomite, and metabolite was 3–30% by weight of lime. Compositions were prepared with a water–lime ratio W/L equal to W/L = 1.25. The samples hardened in air-dry conditions at a temperature of 18–20 °C and a relative air humidity of 60–70%.
Analysis of the granulometric composition of additive based on synthetic aluminosilicates was performed using an automatic laser diffractometer Fritsch Particle Sizer Analysette 22 (Fritsch, Bayern, Germany)
To determine the chemical composition, X-ray fluorescence analysis was performed using X-ray station ARL 9900 X-ray Work Station (Thermo Scientific, Waltham, MA, USA). X-ray diffraction spectra were obtained using λCoKα1,2 radiation. Diffraction angle interval 2θ = 12–80θ, scanning step 0.02θ. For the unambiguous identification of the synthesis products, a full-profile method of quantitative X-ray phase analysis was used, which, along with the Rietveld algorithm, implements the Derivative Difference Minimization algorithm [10,11]. This algorithm is based on minimizing the local derivatives of the difference curve of the experimental and calculated diffraction spectra and eliminates the need for an approximation or numerical description of the background component of the X-ray diffraction pattern.
Structural data for model mineral compositions were used from the International Structural Database (ICSD). The concentration of the amorphous phase was determined using full-profile XRF with internal standardization. Anatase at a concentration of 30% by weight was used as a reference.

3. Results

We studied the influence of the mode of introduction and the amount of aluminum sulfate, the pH of the mixture, and the modulus of liquid glass on the yield of the finished product (Table 1).
It has been established that, at a pH level of aluminum sulfate solution Al2(SO4)3 equal to pH ≥ 5, no precipitate is formed. The minimum yield of the product is 33.12% and is observed at the pH of the solution of aluminum sulfate Al2(SO4)3 equal to pH = 3; moreover, the maximum yield (45.87%) is observed at the pH of the solution of aluminum sulfate Al2(SO4)3 equal to pH = 1.5. An increase in the liquid glass modulus from 2.69 to 2.88 leads to an increase in the yield of finished products from 44.76% to 45.87%.
As a criterion for the optimal technology for obtaining the additive, the compressive strength of the lime composite was recorded, since the additive was subsequently intended for use in lime systems. Table 2 shows the results of the studies of the dependence of the strength of a lime composite with an additive obtained at different densities of liquid glass. Lime of the first grade with an activity of 84.4% was used, and the water–lime ratio is W/L = 1.25.
It has been established that the maximum strength of lime specimens with an additive based on synthetic aluminosilicates, which is R = 3.25 MPa, is observed at a density of liquid glass used in the synthesis of the additive, equal to ρ = 1368 kg/m3.
The German standard DIN 18550 (part 2) notes that durability and resistance to external influences, as well as high crack resistance, are ensured when the plaster mortar has a compressive strength in the range of 2 to 5 MPa. Solutions with such strength characteristics are able to adapt to small deformations and resist cracking. Based on this, for the sake of economy, the optimal mode was chosen: the density and modulus of liquid glass are, respectively, ρ = 1279 kg/m3, M = 2.88, pH of aluminum sulfate Al2(SO4)3 solution pH = 3 [12,13].
The resulting product is a white powder with a specific surface area determined using the Brunauer–Emmett–Teller (BET) method, Ssp = 86.5 m2/g. The chemical composition of additives based on synthetic zeolite is presented in Table 3.
Analyzing the data obtained in Table 3, a high content of the chemical elements O, Si, and Na was revealed, amounting to 46.47–61.58%, 20.78–39.60%, and 5.54–16.52%, respectively, which indicates the predominance of oxides of the corresponding elements. The oxide composition is presented in Table 3 and Table 4. It has been established that silica oxides predominate, constituting 56.21–55.45% (Table 4).
The X-ray diffraction pattern of the material is characterized by the presence of selective diffraction reflections and a pronounced structured background (“diffuse halo”). Based on X-ray diagnostics performed using the PDF 2 database of the International Center for Diffraction Data (ICDD) using the SearchMatchv.2 program, it was found that the crystalline part of the additive based on synthetic zeolite is represented by thenardite, a rhombic modification of sodium sulfate Na2SO4 (PDF 70-1541). In addition, a weak reflection at 2θ = 21.29° was attributed to gibbsite (PDF 70-2038) (Figure 1).
X-ray diffraction analysis (XRF) revealed that the composition of the additive is represented by the following minerals: thenardite Na2SO4 (d = 4.6677; d = 3.8638; d = 3.0829; d = 2.3327); gibbsite Al(OH)3 (d = 3.1899; d = 1.6820); minerals of the zeolite group (d = 2.7907; d = 2.6558; d = 1.8679) (Figure 1) [14,15,16].
Figure 2 shows the result of quantitative XRF in the variant of calculating the concentrations of crystalline phases. The results obtained are consistent with the chemical analysis data:
Camorph = ∑Ci − (CNa2O + CSO3) = 77.5%
The results obtained are in good agreement with the data of the authors [17,18].
The question of the structural nature of the resulting amorphous phase of the aluminosilicate composition requires separate consideration. According to [19], the characteristic that determines the structural motif of silica in amorphous phases can be the Si/O ratio, which is defined as the degree of silica connectivity in silicate clusters of the glass phase.
The coefficient fSi is equal to the ratio of the number of silicon ions to the number of oxygen ions and expresses the degree of bonding of the silicon–oxygen framework. The coefficient fSi reflects the nature of the structure of silicates and the state of structural units, namely, silicon–oxygen tetrahedra. The type of silicon–oxygen radical according to the Si/O ratio is continuous in three dimensions; in this case, fSi is equal to 0.5. This indicates the framework structure of silica clusters in the amorphous material.
The microstructure of the resulting additive was studied using an electron microscope at a magnification of 20.000 times (Figure 3).
It has been established that the structure of the additive is represented mainly by particles, the size of which is 2.25–8.1 nm.
Table 5 shows the activity values of additives based on synthetic aluminosilicates, depending on the mode of its production.
Additives based on synthetic aluminosilicates are characterized by the high activity of more than 350 mg/g. The solubility of the additive prepared according to the first mode is M = 89.03%, the additive prepared according to the fourth mode is M = 67.63%, and the cation exchange capacity is E = 38.7–43.51 mg·eq. An analysis of particle size distribution, performed using an automatic laser diffractometer Fritsch Particle Sizer Analysette 22, showed that less than 0.01% are particles with a size of 0.010–0.500 µm, and that the content of particles with a size of 100.000–200.000 µm is 0.44%. Less than 5% are particles with a diameter of 3.226 microns; less than 15% are particles with a diameter of 6.985 microns (Table 6).
To assess the sorption properties of the additive, sorption moisture was determined. When studying the kinetics of moisture sorption, the samples were predried in an oven at a temperature of t = 110 °C to a constant weight and placed in desiccators with different relative humidity φ = 18–97% and a constant temperature t = 20 ± 2 °C. Based on the data obtained, sorption and desorption isotherms were constructed (Figure 4).
Moisture sorption in the range of relative air humidity up to 18% obeys Henry’s law, i.e., the dependence of sorption humidification on the value of relative air humidity is close to linear. With an increase in the relative humidity of the air up to 40%, the moisture content in the samples increases in accordance with the Freundlich equation. The convex part of the isotherms (φ = 60–80%) indicates the presence inside the studied samples of only adsorbed moisture, consisting of a single layer of water vapor molecules. An increase in the relative air humidity to 90% leads to the formation of adsorbed moisture films on the inner surface of the material, consisting of many layers of molecules. Starting from 80% humidity, there is a sharp increase in sorption moisture, which indicates the occurrence of the process of capillary condensation.
Sorption and desorption isotherms coincide only at very low and very high values of relative air humidity; at other values, they do not coincide. The sorption isotherms are located lower than the desorption isotherms, and the equilibrium moisture content at the same value of the relative air humidity during moisture desorption is less than during moisture sorption. The bulk density of the additive based on synthetic aluminosilicates is ρset = 231 kg/m3, and the true ρact = 568.515 kg/m3.
An analysis of the experimental data indicates that, with the introduction of an additive based on synthetic aluminosilicates in an amount of 10%, the strength is 94.25% higher than that of the control sample; with the introduction of meta kaolinite in an amount of 10%, the strength increases by 26.35% compared with the control sample; moreover, with the introduction of diatomite in an amount of 10%, the strength compared with control samples decreases by 6.08% (Table 7).
However, the preparation of meta kaolinite (roasting at a temperature of 900 °C) is an energy intensive process; therefore, it is more appropriate to use an additive based on synthetic aluminosilicates.
X-ray diffraction analysis (XRD) revealed that, when an additive based on synthetic aluminosilicates is added to lime, the following are formed: zeolites (d = 3.036; d = 2.627; d = 1.687); portlandite Ca(OH)2 (d = 4.911; d = 3.11; d = 1.876); calcite CaCO3 (d = 2.491; d = 2.094; d = 2.491); calcium hydro silicate - sodium CaNaHSiO4 (d = 1.926; d = 1.91; d = 2.287) (Figure 5) [20,21,22,23,24,25,26,27].
The thermodynamic analysis of possible solid-phase isobaric–isothermal reactions was carried out in accordance with the second law of thermodynamics, which establishes a relationship between the thermal effect of a chemically irreversible process and the work of the corresponding irreversible process and is determined using the Gibbs–Helmholtz equation:
Δ G = Δ H p + T · δ Δ G δ T
where,
  • ΔG is the Gibbs energy;
  • ΔHp is process enthalpy;
  • T is temperature, K.
Considering that the synthesis of the additive proceeds at a temperature (293 K) close to the standard one (298 K), the thermal effect of the reaction and the change in the Gibbs energy were determined only at the standard state and were calculated as the difference between the sums of the corresponding indicators of the reaction products and starting substances. The results of the calculations of thermodynamic parameters are presented in Table 8. The results of the calculations indicate the probability of reactions proceeding in the forward direction. Large numerical values Δ G 298 0 allow us to speak with sufficient probability about the possibility of these reactions occurring not only at the standard temperature (25 °C), but also at other temperatures.
The results of the thermodynamic calculations suggest that the most probable mechanism causing the hardening process is the formation of calcite, calcium sodium hydro silicate, minerals of the zeolite group, and portlandite.
Additional confirmation of the chemical interaction of the additive with lime is provided by the amount of chemically bound lime. It has been established that the amount of chemically bound lime in control samples (lime + water) at the age of 28 days of air-dry hardening is 46.5%, and, with the use of an additive based on synthetic aluminosilicates, it is 55.28% (Figure 6).

4. Conclusions

A technology has been developed for obtaining an additive based on synthetic zeolites, which consists of the precipitation of aluminosilicates from sodium water glass with aluminum sulfate Al2(SO4)3. The optimal parameters of the technology for obtaining the additive were established: the density and modulus of liquid glass are, respectively, ρ = 1279 kg/m3 and M = 2.88, the pH of aluminum sulfate Al2(SO4)3 pH = 3.
X-ray diffraction analysis and thermodynamic calculations have established that the mineralogical composition of the crystalline phase of the additive based on synthetic aluminosilicates is represented by the thenardite, gibbsite, and minerals of the zeolite group. It has been shown that the content of the amorphous phase is 77.5%. It was revealed that the additive based on synthetic aluminosilicates is characterized by high activity, which is more than 350 mg/g. An analysis of the granulometric composition, performed using an automatic laser diffractometer Fritsch Particle Sizer Analysette 22, revealed that less than 0.01% are particles with a size of 0.010–0.500 µm, and that the content of particles with a size of 100.000–200.000 µm is 0.44%. Less than 5% are particles with a diameter of 3.226 microns, and less than 15% are particles with a diameter of 6.985 microns. The true density of the synthesized aluminosilicates is ρest = 568.515 kg/m3, and the bulk density ρsat = 231 kg/m3; moreover, the cation exchange capacity is E = 38.7–43.51 mg eq.
It was found that the introduction of an additive based on synthetic aluminosilicates into the formulation of a lime dry mixture accelerates the curing of coatings. The optimal concentration of the additive was selected, which is 10% by weight of lime. It has been shown that the introduction of an additive based on synthetic aluminosilicates into the lime–sand composition contributes to an increase in compressive strength at the age of 28 days of air-dry hardening by 1.9 times.
X-ray diffraction analysis, thermodynamic calculations, and chemical analysis revealed that samples based on lime compositions with an additive based on synthetic aluminosilicates are characterized by the content of the calcium–sodium hydrosilicates, calcite, calcium hydroxide, and minerals of the zeolite group, an increase in the amount of chemically bound lime by 8.74%.

Author Contributions

Conceptualization, V.I.L.; methodology, V.I.L.; software, V.I.L.; validation, V.I.L., K.V.Z. and M.A.S.; formal analysis, K.V.Z.; investigation, M.A.S.; resources, K.V.Z.; data curation, M.A.S.; writing—original draft preparation, M.A.S.; writing—review and editing, K.V.Z.; visualization, V.I.L., K.V.Z. and M.A.S.; supervision, K.V.Z.; project administration, V.I.L. All authors have read and agreed to the published version of the manuscript.

Funding

This research received no external funding.

Data Availability Statement

The data that support the findings of this study are available on request from the corresponding author.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Volkov, V.A.; Vonsky, V.A.; Kuznetsova, G.I. Outstanding Chemistry of the World; Graduate School: Moscow, Russia, 1991; 656p. [Google Scholar]
  2. Brek, D. Zeolite Molecular Sieves; Mir Publishers: Moscow, Russia, 1970; 328p. [Google Scholar]
  3. Rabo, J. Chemistry of Zeolites and Catalysis on Zeolites Per. from English, T. 1; Mir Publishers: Moscow, Russia, 1980; 506p. [Google Scholar]
  4. Nam, L.S.; Shumovsky, A.V.; Malyutin, S.A. Method for Obtaining Zeolite. RU Patent 2083493, 7 March 1995. [Google Scholar]
  5. Kazantseva, L.K. Method for Producing NaA or NaX Zeolite. RU Patent 2452688, 22 February 2011. [Google Scholar]
  6. Leontyeva, T.G.; Baklay, A.A.; Moskalchuk, L.N. Prospects for the use of clay-salt sludge of JSC “Belaruskali” for the purification of aquatic environments and ecosystems from radiocesium. Proc. BSTU. 2016, 3, 74–80. [Google Scholar]
  7. Kharitonov, V.P.; Alekseeva, G.N.; Gnezdinov, A.A.; Savina, N.F.; Kovalev, V.M. Method for Producing Sodium Aluminosilicate. RU Patent 2044689, 16 June 1992. [Google Scholar]
  8. Melikyan, A.A.; Melikyan, S.A.; Melikyan, A.A.; Babayan, G.G.; Sychev, V.M. Method for Producing Amorphous Aluminosilicate. RU Patent 2106303, 10 March 1998. [Google Scholar]
  9. Tsarev, N.S. Dehydration of sludge in wastewater treatment and industrial rain sewerage using aluminosilicate sorbents and flocculants. Water Treat. 2012, 9, 37–47. [Google Scholar]
  10. de Pietre, M.K.; Freitas, J.C.C. Fundamental studies on zeolite–adsorbate interactions: Designing a better aluminosilicate adsorbent for pollutants’ removal. Environ. Earth Sci. 2022, 81, 17. [Google Scholar] [CrossRef]
  11. Loganina, V.; Zhegera, K.; Fediuk, R.; Timokhin, R.; Zayakhanov, M.; Liseitsev, Y. Amorphous Aluminosilicates as a Structure-Forming Additive in Cementitious Systems. J. Mater. Civil Eng. 2020, 32, 06020004. [Google Scholar] [CrossRef]
  12. Loganina, V.I.; Ryzhov, A.D. Structure and properties of synthesized additive based on amorphous aluminosilicates. Case Stud. Constr. Mater. 2015, 3, 132–136. [Google Scholar] [CrossRef] [Green Version]
  13. Loganina, V.I.; Makarova, L.V.; Tarasov, R.V.; Sadovnikova, M.A. Composition limy binder with the use of the synthesized alumiosilicates for dty construction blends. Adv. Mater. Res. 2014, 977, 34–37. [Google Scholar] [CrossRef]
  14. Lahnafi, A.; Elgamouz, A.; Tijani, N.; Jaber, L.; Kawde, A.-N. Hydrothermal synthesis and electrochemical characterization of novel zeolite membranes supported on flat porous clay-based microfiltration system and its application of heavy metals removal of synthetic wastewaters. Microporous Mesoporous Mater. 2022, 334, 111778. [Google Scholar] [CrossRef]
  15. Xu, H.; Zhu, L.; Wu, Q.; Meng, X.; Xiao, F.-S. Advances in the synthesis and application of the SSZ-39 zeolite. Inorg. Chem. Front. 2022, 9, 1047–1057. [Google Scholar] [CrossRef]
  16. Okhrimenko, D.V.; Barly, S.H.Q.; Jensen, M.; Lakshtanov, L.Z.; Johansson, D.B.; Solvang, M.; Yue, Y.Z.; Stipp, S.L.S. Surface evolution of aluminosilicate glass fibers during dissolution: Influence of pH, solid-to-solution ratio and organic treatment. J. Colloid Interface Sc. 2022, 606, 1983–1997. [Google Scholar] [CrossRef] [PubMed]
  17. Zemnukhova, L.A.; Fedorishcheva, G.A.; Tsoi, E.A.; Arefieva, O.D. Method for producing sodium or potassium aluminosilicates from silicon-containing vegetable raw materials. RU Patent 2557607, 27 July 2015. [Google Scholar]
  18. Akkerman, R.C.; Gabriel, M.C.; Smigal, J.A.; Van Ven Johannes, A.R. Composition of an Amorphous Aluminosilicate and a Method for Obtaining and Using Such a Composition. USA Patent 6872685, 10 October 2012. [Google Scholar]
  19. Appen, A.A. Chemistry of Glass; Publishing House “Chemistry” Leningrad Branch: Leningrad, Russia, 1974; 352p. [Google Scholar]
  20. Volodchenko, A.; Lesovik, V.; Volodchenko, A.; Cherepanova, I. Investigation of the synthesized calcium hydrosilicates effect on the properties of energy-saving wall silicate blocks obtained on the basis of technogenic raw materials. Mater. Sci. Forum 2021, 1043, 93–99. [Google Scholar] [CrossRef]
  21. Bryden, R.H.; Goski, D.G.; Caley, W.F. Lime-Alumina-Silica processing incorporating minerals. J. Eur. Ceram. Soc. 1999, 19, 1599–1604. [Google Scholar] [CrossRef]
  22. Gonzalez-Panicello, L.; Garcia-Lodeiro, I.; Puertas, F.; Palacios, M. Influence of Accelerating Admixtures on the Reactivity of Synthetic Aluminosilicate Glasses. Materials 2022, 15, 818. [Google Scholar] [CrossRef] [PubMed]
  23. Sánchez-Muñoz, L.; Sanz, J.; Florian, P.; Diez-Gómez, V.; Furio, M.; Sobrados, I. Order-Disorder in the Structures of Lithium Aluminosilicate Minerals by XRD and Multinuclear NMR. Minerals 2022, 12, 427. [Google Scholar] [CrossRef]
  24. Loganina, V.I.; Zhegera, K.V. The Topology Structure of Cement Stope with the Use of Compounding Additive Based on Amorphous Aluminosilicates. Solid State Phenom. 2018, 279, 271–275. [Google Scholar] [CrossRef]
  25. Kaeding, W.W.; Chu, C.-C.; Young, L.B.; Butter, S.A. Shape-selective reactions with zeolite catalysts. II. Selective disproportionation of toluene to produce benzene and p-xylene. J. Catal. 1981, 69, 392–398. [Google Scholar] [CrossRef]
  26. Andrejkovicova, S.; Ferraz, L.; Velosa, A.L.; Silva, A.S.; Air, F.R. Lime mortars with incorporation of sepiolite and synthetic zeolite pellets. Acta Geodyn. Geomater. 2012, 9, 79–91. [Google Scholar]
  27. Aiello, R.; Collela, C.; Sersale, R. Molecular sieve zeolites. Adv. Chem. Ser. Wash. 1971, 101, 51. [Google Scholar]
Figure 1. X-ray pattern of additives based on synthetic aluminosilicates.
Figure 1. X-ray pattern of additives based on synthetic aluminosilicates.
Physchem 03 00013 g001
Figure 2. The result of the full quantitative XRF.
Figure 2. The result of the full quantitative XRF.
Physchem 03 00013 g002
Figure 3. Microstructure of additives based on synthetic aluminosilicates ×20,000.
Figure 3. Microstructure of additives based on synthetic aluminosilicates ×20,000.
Physchem 03 00013 g003
Figure 4. Sorption and desorption isotherms of an additive based on synthetic aluminosilicates: 1—sorption isotherm; 2—desorption isotherm.
Figure 4. Sorption and desorption isotherms of an additive based on synthetic aluminosilicates: 1—sorption isotherm; 2—desorption isotherm.
Physchem 03 00013 g004
Figure 5. X-ray diffraction pattern of a lime composite in the presence of a synthetic zeolite additive.
Figure 5. X-ray diffraction pattern of a lime composite in the presence of a synthetic zeolite additive.
Physchem 03 00013 g005
Figure 6. Change in the amount of bound lime during the hardening process 1—control; 2—with the use of an additive based on synthetic aluminosilicates.
Figure 6. Change in the amount of bound lime during the hardening process 1—control; 2—with the use of an additive based on synthetic aluminosilicates.
Physchem 03 00013 g006
Table 1. Aluminosilicates synthesis regimes.
Table 1. Aluminosilicates synthesis regimes.
No. of
Synthesis Mode p/p
pH of Aluminum
Sulfate Solution Al2(SO4)3
Liquid Glass Module a *Filtrate pHFinished
Product Yield, %
15.02.69--
23.02.699.0041.90
31.502.699.0038.90
45.002.88--
53.002.889.0034.00
61.502.889.0042.90
75.002.69--
83.002.695.0040.48
91.502.695.0044.76
105.002.88--
113.002.885.0033.12
121.502.885.0045.87
Note: * Density of liquid glass was ρ = 1279 kg/m3.
Table 2. Dependence of the strength of the lime composite with an additive synthesized at different densities of liquid glass.
Table 2. Dependence of the strength of the lime composite with an additive synthesized at different densities of liquid glass.
No.Liquid Glass Density, kg/m3Compressive Strength of Lime Composite, MPa
113683.25
212792.61
311801.82
411131.76
510381.61
Note: The data were obtained at the pH of aluminum sulfate Al2(SO4)3 solution equal to pH = 3.
Table 3. The content of chemical elements in the additive based on synthetic aluminosilicates, %.
Table 3. The content of chemical elements in the additive based on synthetic aluminosilicates, %.
The Content of Chemical Elements in Weight%ONaAlSiS
Maximum62.5816.528.0539.608.94
Minimum46.675.541.8820.780.89
Table 4. The content of oxides presents in the additive based on synthetic aluminosilicates.
Table 4. The content of oxides presents in the additive based on synthetic aluminosilicates.
Name OxideContent, %
SiO256.21–55.45
Al2O321.24–7.58
SO316.79–8.91
Na2O19.10–13.91
CaO0.15–0.0938
Table 5. Properties of additive based on synthetic aluminosilicates.
Table 5. Properties of additive based on synthetic aluminosilicates.
Synthesis ModeMixture pHSuspension pH AdditivesSolubility M, %Activity A, mg/g
14.8310.0189.03350
26.3110.2474.36350
39.2610.4874.16350
410.5010.5067.63350
Table 6. Granulometric composition of the additive.
Table 6. Granulometric composition of the additive.
Fraction, μmThe Percentage Content, %
0.01–0.500.01
0.50–2.001.81
2.00–3.002.55
3.00–4.002.8
4.00–5.002.73
5.00–10.0012.61
10.00–20.0016.61
20.00–45.0027.2
45.00–80.0029.14
80.00–100.004.09
100.00–200.000.44
Table 7. The value of the compressive strength of lime composites with additives after 28 days.
Table 7. The value of the compressive strength of lime composites with additives after 28 days.
AdditivePercentage, %
35102030
Compressive Strength, MPa
Control (lime:water)1.48
Diatomite0.9521.231.392.462.76
Meta kaolinite2.3252.453.353.854.5
Additive based on synthetic aluminosilicates2.2752.482.8753.13.54
Table 8. Thermodynamic parameters of isobaric–isothermal reactions for the production of synthetic aluminosilicates.
Table 8. Thermodynamic parameters of isobaric–isothermal reactions for the production of synthetic aluminosilicates.
Formula of the CompoundHeat of Formation, Δ H 298 0 kJ/mol Gibbs Energy of Formation, Δ G 298 0 kJ/molReactions
Na2SO4−1389.5−1271.7Al2(SO4)3 + 4Na2SiO3 + 2H2O =
2NaAlSi2O6·H2O + 3Na2SO4
Al(OH)3−1275.7−1139.7Al2(SO4)3 + 3Na2SiO3 + 3H2O =
2Al(OH)3 + 3Na2SO4 + 3SiO2
NaAlSi2O6·H2O−682.68−732.48Al2(SO4)3 + 4Na2SiO3 + 2H2O =
2NaAlSi2O6·H2O + 3Na2SO4
Na2Al2Si3O10·2H2O−1128.3−984.1Al2(SO4)3 + 4Na2SiO3 + 2H2O =
Na2Al2Si3O10·2H2O + 3Na2SO4 + SiO2
NaAlSi5O12·3H2O−937.59−765.561.5Al2(SO4)3 + 5Na2SiO3 + 6H2O =
NaAlSi5O12·3H2O + 4.5Na2SO4 + 2Al(OH)3
Disclaimer/Publisher’s Note: The statements, opinions and data contained in all publications are solely those of the individual author(s) and contributor(s) and not of MDPI and/or the editor(s). MDPI and/or the editor(s) disclaim responsibility for any injury to people or property resulting from any ideas, methods, instructions or products referred to in the content.

Share and Cite

MDPI and ACS Style

Loganina, V.I.; Zhegera, K.V.; Svetalkina, M.A. Additive Based on Synthetic Aluminosilicates for Dry Lime Construction Mixtures. Physchem 2023, 3, 198-209. https://doi.org/10.3390/physchem3010013

AMA Style

Loganina VI, Zhegera KV, Svetalkina MA. Additive Based on Synthetic Aluminosilicates for Dry Lime Construction Mixtures. Physchem. 2023; 3(1):198-209. https://doi.org/10.3390/physchem3010013

Chicago/Turabian Style

Loganina, Valentina Ivanovna, Kristina Vladimirovna Zhegera, and Maria Anatolyevna Svetalkina. 2023. "Additive Based on Synthetic Aluminosilicates for Dry Lime Construction Mixtures" Physchem 3, no. 1: 198-209. https://doi.org/10.3390/physchem3010013

Article Metrics

Back to TopTop