Next Article in Journal
Synergistic Effect of Combination of Various Microbial Hurdles in the Biopreservation of Meat and Meat Products—Systematic Review
Previous Article in Journal
Alleviation of Alcoholic Fatty Liver by Dendrobium officinale Flower Extracts due to Regulation of Gut Microbiota and Short-Chain Fatty Acids in Mice Exposed to Chronic Alcohol
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Communication

The Retention of Vitamin D2 and 25-Hydroxyvitamin D2 in Pulse UV-Irradiated Dried Button Mushrooms (Agaricus bisporus) after 12 Months of Storage

1
Curtin School of Population Health, Curtin University, Bentley, WA 6102, Australia
2
Food Futures Institute, Murdoch University, Murdoch, WA 6150, Australia
3
National Measurement Institute, Port Melbourne, VIC 3207, Australia
*
Author to whom correspondence should be addressed.
Foods 2023, 12(7), 1429; https://doi.org/10.3390/foods12071429
Submission received: 8 February 2023 / Revised: 20 March 2023 / Accepted: 23 March 2023 / Published: 28 March 2023
(This article belongs to the Section Plant Foods)

Abstract

:
Fresh mushrooms exposed to ultraviolet (UV) radiation prior to drying generate high concentrations of vitamin D2. The aim of this study was to determine the retention of D vitamers in mushrooms that were pulse UV irradiated, then air dried, and stored for up to 12 months. Fresh button mushrooms (A. bisporus) were exposed to pulsed UV radiation (dose 200 mJ/cm2, peak of 17.5 W/cm2), air dried and vacuum sealed before being stored in the dark at room temperature. After storage, samples were freeze dried and quantified for D vitamers using triple quadrupole mass spectrometry. After 3, 6 and 12 months of storage, there was 100% (11.0 ± 0.8 µg/g dry weight (DW), 93% (10.1 ± 0.6 µg/g DW) and 58% (5.5 ± 0.6 µg/g DW) retention of vitamin D2 and 88% (0.14 ± 0.01 µg/g DW), 71% (0.11 ± 0.01 µg/g DW) and 68% (0.1 ± 0.01 µg/g DW) retention of 25-hydroxyvitamin D2 (25(OH)D2), respectively. Compared to the irradiated dried mushrooms that were not stored, the D vitamer concentration was statistically significantly lower (p < 0.05) at 6 and 12 months for 25(OH)D2 and at 12 months for vitamin D2. Sufficient vitamin D2 (99 µg) remained after 12 months storage to provide at least 100% of daily dietary vitamin D requirements in a 20 g serving.

1. Introduction

Vitamin D deficiency is prevalent worldwide, partly because there is low consumption of dietary vitamin D [1,2,3,4], and partly because of cultural norms or measures to reduce sun exposure to potentially damaging ultraviolet (UV) radiation [5,6]. Very few foods are a good source of vitamin D, the exceptions being meat, fish and egg yolk, and foods that have been fortified with vitamin D. Mushrooms generate vitamin D2 and 25-hydroxyvitamin D2 (25(OH)D2) when exposed to ultraviolet (UV) radiation such as solar radiation or UV lamps, with UV-B radiation being the most effective wavelength range [7,8,9]. UV radiation splits the B ring of ergosterol (pro-vitamin D2) between carbons 9 and 10, converting it into pre-vitamin D2. This structure is then rapidly rearranged in a heat-dependent process to an isomer known as ergocalciferol or vitamin D2 [10].
Cytochrome P450 enzymes present in the mushrooms appear to be responsible for hydroxylating vitamin D2 to 25(OH)D2 [11,12], although this occurs in mushrooms only if they are irradiated before drying and not vice versa [13]. Consumption of UV-irradiated mushrooms has been shown to increase serum 25(OH)D levels, particularly in consumers with a low vitamin D status (<50 nmol/L) [14,15]. There was little effect when the vitamin D status was high as the rise in 25(OH)D2 was offset by a fall in serum 25(OH)D3.
The amount of D vitamers produced by UV radiation will depend on the dose, the UV wavelength, the form of the mushrooms (sliced, whole, dried or powdered), the orientation of the mushrooms and the ambient temperature [7,16]. UV-exposed dried mushrooms can be a convenient and valuable source of vitamin D, especially for those wishing to limit their exposure to sunlight or avoid animal-derived dietary products [8,17,18].
Wild mushrooms that have been exposed to sunlight while growing or drying will naturally generate vitamin D2 [19,20,21]. Commercial dried mushrooms are normally sun-dried or hot-air dried, the former resulting in production of vitamin D2 [21,22]. Commercial dried mushrooms are often labelled with a shelf life of 12–18 months after packaging. Some countries permit dried mushrooms to be sold for up to 24 months after packaging, although there may be significant deterioration in quality and antioxidant activity beyond 12 months of storage [23].
Very little is known about the long-term retention of D vitamers in dried mushrooms, although there are some studies on both the short-term retention of vitamin D2 in fresh mushrooms and the long-term retention in frozen, powdered or dried mushrooms. The retention of vitamin D2 in UV-irradiated fresh mushrooms when refrigerated over periods of up to 14 days have showed varying results, with losses up to 50% [24,25,26,27]. Wild mushrooms retained virtually all their vitamin D2 after being frozen for 9 months [28]. Powdered, then pulse UV-irradiated oyster mushrooms stored for 60 days at room temperature (25 °C) or refrigerated (4 °C) retained 62% and 71% of their vitamin D2, respectively [29]. UV-B-irradiated, air-dried, button mushrooms stored at room temperature (22 °C) retained 54% of their vitamin D2 after 12 months and 48% after 18 months [17].
The long-term retention of both vitamin D2 and 25(OH)D2 has not yet been investigated in pulse UV-irradiated whole fresh button mushrooms (Agaricus bisporus) that were subsequently air dried. The aim of this study was to determine and compare the retention of vitamin D2 and 25(OH)D2 in button mushrooms that were pulse UV irradiated then hot-air dried, and packed and stored in similar conditions as retail dried mushrooms kept in the home.

2. Materials and Methods

2.1. Mushroom Samples

In November 2020, twelve 200 g samples (Batch 1) of fresh button mushrooms (Agaricus bisporus), 4.5–5.5 cm in diameter and a mean weight of 28.6 g, were provided by a commercial farm (Costa Mushrooms) in Perth, Western Australia (Figure 1). A further thirteen 200 g samples of the same size (Batch 2) were collected from the same farm in January 2022. The mushrooms were harvested as they would be for market, with the stipe connected to the cap and the skirt intact.
The mushrooms were packed in boxes that were cooled, insulated and sealed from light, then transported by road to the laboratory at Curtin University (travel time 30 min). All samples were stored at 4 °C and processed within 48 h of collection. For 2 h prior to processing the samples were left at 23 °C, with any residual compost brushed off.

2.2. Baseline Samples

Baseline samples were analysed to confirm no unintended UV-radiation exposure, such as sunlight, had occurred prior to treatment. Four 200 g fresh samples were randomly selected from Batch 1 and one 200 g sample was randomly selected from Batch 2. The samples were sliced and placed in a freezer at −20 °C and lyophilised in a freeze dryer (Christ Alpha 1-2 LD plus, Martin Christ Gefriertrocknungsanlagen GmbH, Osterode am Harz, Germany) for 48 h at −30 °C and 37 pascals. The dry matter was made into a fine powder and stored at −20 °C.

2.3. UV-Irradiated then Air-Dried Samples (No Storage)

Four samples of 200 g whole mushrooms from both Batch 1 and Batch 2 were UV irradiated using a pulsed xenon lamp (Wek-tec XematicA-2L, Wek-tec e. K., Gottmadingen, Germany; emitting at 260–800 nm) with the skirted underside of each mushroom facing the lamp. The distance between the lamp and the mushrooms was 10 cm. The average dose of 200 mJ/cm2 and a peak of 17.5 W/cm2 were recorded with a radiometer (ILT800 CureRight, International Light Technologies, Peabody, MA, USA; measuring 215–350 nm).
After irradiation, the mushroom samples were placed in a convection oven and air dried for 18 h at 60 °C (Contherm Thermotec 2000, Contherm Scientific Ltd., Wellington, New Zealand). They were frozen at −20 °C and lyophilised for 24 h to remove any residual moisture and prepared for analysis as in Section 2.2. The shorter time for freeze-drying was due to these air-dried samples having a much lower moisture content compared to the fresh samples described in Section 2.2.

2.4. Storage for 3 and 6 Months

Eight 200 g samples from Batch 2 were UV irradiated and air dried as in Section 2.3. Each sample was individually vacuum sealed in plastic pouches (Laica Advanced Technology, Barbarano Mossano, Italy) and stored for either 3 or 6 months in a light-proof cardboard box at room temperature (January–July 2022). Storing in vacuum-sealed pouches was to mimic the processing of vacuum-packed commercial dried mushrooms that are then stored in a pantry by the consumer without any further exposure to UV radiation (household lights emit mainly visible light and very little UV radiation). During the first three months of storage the average temperature was 23 °C (range 22–25 °C) with an average humidity of 57% (range 43–65%) as measured by a temperature and humidity data logger (Lascar Electronics, EL-USB-2, Hong Kong, China). During the second three months of storage the average temperature was 21 °C (range 18–25 °C) with an average humidity of 53% (range 40–62%). After 3 and 6 months, samples were lyophilised for 24 h and prepared for analysis as in Section 2.2.

2.5. Storage for 12 Months

Four 200 g samples from Batch 1 were prepared as described in Section 2.3 and stored as in Section 2.4. The room temperature (av. 22.6 °C, range 20–26 °C; av. 50.7% humidity, range 47–62%) was measured during the 12 months storage (November 2020–November 2021). After 12 months, samples were lyophilised for 24 h and prepared for analysis as in Section 2.2.

2.6. Transport to Laboratory

After the designated storage time, samples were frozen at −20 °C prior to being sent by overnight courier in light-sealed, cooled, insulated containers for analysis at the National Measurement Institute (NMI) in Melbourne, Australia. On arrival, they were stored at −20 °C until analysis for vitamin D2 and 25(OH)D2, which occurred within 8 weeks.

2.7. Analysis of D-Vitamers

Analysis of each sample was by liquid chromatography coupled with triple quadrupole (LC-QQQ), tandem mass spectrometry. The analysis of D vitamers used NMI’s validated in-house method developed from published methodologies and approved by the National Association of Testing Authorities, Australia (ISO17025:2017) [30]. All samples were analysed in duplicate with the average of the two results being used. The limit of quantitation (LOQ) was 0.001 µg/g DW. The full method and verification has been previously reported [13].

2.8. Statistical Analysis

The Shapiro–Wilk test of normality was conducted on the storage times and retention of D vitamers. Wilcoxin Rank Sum tests were used to test associations between D vitamers at different storage times. Data were analysed using Stata (Version 17.0, StataCorp, College Station, TX, USA).

3. Results

The baseline vitamin D2 and 25(OH)D2 concentrations were both less than the LOQ, giving assurance there was no inadvertent UV radiation exposure prior to treatment. Table 1 shows the concentration of vitamin D2 and 25(OH)D2 in samples that were not stored, and after 3, 6 and 12 months of storage.

3.1. Vitamin D2

The average retention of vitamin D2 was 100% after three months of storage, and 93% after six months, neither being statistically significant different to the concentration in the samples that were not stored. However, only 58% of the original concentration was retained (p = 0.025) after 12 months storage.

3.2. 25-Hydroxyvitamin D2

The retention of 25(OH)D2 was 88% after three months which was not significantly different compared to the samples that were not stored. After 6 and 12 months of storage, there was a further drop to 71% and 68% retention, respectively, which was statistically significantly different to the original concentration (p = 0.029).

4. Discussion

4.1. Vitamin D2

There was little to no loss of vitamin D2 in whole UV-irradiated dried mushrooms stored for 3–6 months, with most of the loss occurring in the second six months of storage. There are only two studies on the long-term retention of vitamin D2 in UV-irradiated dried mushrooms. In a study, A. bisporus mushrooms were first irradiated, then air dried in a convection oven, before being stored in sealed bags at a room temperature of 20 ± 2 °C [17]. After 3, 8, 12 and 18 months, respectively, 81%, 65%, 54% and 48% of the original concentration of vitamin D2 remained. The retention of vitamin D2 after 12 months of storage was similar to our findings (25(OH)D2 was not measured). The second study was of oyster mushrooms that were freeze dried, powdered, then pulse UV irradiated and kept at room temperature (25 °C) without light exposure for 60 days. The vitamin D2 concentration dropped from the initial 65.4 to 40.8 µg/g DW at day 60, approximating a 62% retention of the original concentration [29].
Few studies have assessed the vitamin D2 retention in fresh UV-irradiated button mushrooms when stored at room temperature. Two studies found no evidence of vitamin D2 degradation, neither in whole mushrooms stored for 8 days at 25 °C [31], nor sliced mushrooms stored for 5 days at 30 °C [24]. In studies of the retention of vitamin D2 in UV-irradiated mushrooms during refrigeration the findings are not consistent. Vitamin D2 in UV-irradiated whole button mushrooms decreased by about half (from 14.8 to 6.2 µg/g DW) over 7 days at 4 °C [25]. In a study of pulse UV-irradiated sliced button mushrooms stored at 3 °C, the vitamin D2 dropped from 11.9 to 9.1 µg/g DW over three days then remained stable for a further 8 days [26]. Sliced button mushrooms refrigerated at 4 °C for four days showed no overall change in vitamin D2, although there was a rise and a fall in concentrations within that four days [24]. The vitamin D2 concentration was stable in white and brown whole button mushrooms, with a trend for the vitamin D2 to rise in the stems of brown button mushrooms, when stored at 4 °C for up to 14 d [27].
There appears to be good vitamin D2 retention in UV-irradiated dried mushrooms. The decline in vitamin D2 concentration in dried mushrooms occurs primarily after six months storage at 20–23 °C. However, if the original vitamin D2 concentration is sufficiently elevated (about 10 µg/g DW in this study and 14 µg/g DW in Sławińska et al. [17]), even if only half remains after 12 months storage there will still be 100–140 µg vitamin D2 in a 20 g serving, sufficient to satisfy vitamin D dietary requirements.

4.2. 25-Hydroxyvitamin D2

Fresh mushrooms were irradiated before air-drying as we have previously shown that irradiated mushrooms will generate 25(OH)D2, while irradiating dried mushrooms does not generate any 25(OH)D2 [13]. Another study has measured the concentration of 25(OH)D2 in button mushrooms with the concentration being below the level of detection [19]. Even at 0.1 µg 25(OH)D2/g DW, as found in the current study after 12 months storage, a 20 g serving will provide about 2.0 µg which is potentially nutritionally useful.

4.3. Effect of UV-Irradiation and Air-Drying

The concentration of D vitamers is likely to have been higher if the mushrooms were sliced or the gills were uncovered before UV exposure. Sliced mushrooms have a greater surface area for potential irradiation than whole mushrooms [26]. The gills of shiitake mushrooms have a higher concentration of ergosterol than the rest of the mushroom [32], while irradiating the gill side of button mushrooms produced more vitamin D2 than when the pileus side faced the UV-B radiation source [33].
After air-drying irradiated mushrooms, the low moisture content of the dried mushrooms may slow the rate of degradation of vitamin D2 [32]. The half-life of D2 in air-dried, UV-irradiated and powdered oyster mushrooms (Pleurotus ostreatus) was dependent on the storage temperature and water activity (aw) in the powder [34]. At a storage temperature of 20 °C and a water activity of 0.32 (aw 0.32; distilled water has a aw of 1.0), the half-life of vitamin D2 was 160 days, and 225 days in samples with a very low water activity (aw 0.11).

4.4. Uses of Dried Vitamin D-Enriched Mushrooms

The UV dosage was chosen as it generated enough D vitamers to be of value in human nutrition. The serving size of dried mushrooms stated on commercial packs ranges between 10 and 30 g. Therefore, assuming a serving size of 20 g, our data show that a serving of irradiated, then air-dried mushrooms would offer approximately 99 µg D2 after 12 months storage. This is more than the vitamin D recommended daily intake in Australia (5–15 µg in adults) [35], Europe (15 µg) [36], the Nordic countries (10–20 µg) [37] and the USA (15–20 µg) [38]. The dose of UV radiation could be adjusted to generate D vitamer concentrations to suit local needs.
A higher radiation dose than used in this study would have generated greater amounts of the D vitamers, at a concentration potentially suitable for use as a powdered supplement. UV-irradiated whole, sliced or powdered dried mushrooms can be used as a supplemental vitamin D food product or an ingredient in functional foods, suited to those at a high risk of vitamin D deficiency [39]. The European Food Safety Authority has stated that UV-irradiated powdered mushrooms can be used as a novel food ingredient providing supplemental vitamin D2 [40]. Although the intended shelf life of the mushroom powder is two years, the results of their tests showed that the powder was stable for at least three years. The European Commission has also authorized the use of UV-treated mushrooms as a novel food [41].
Knowing the retention of D vitamers in stored dried mushrooms is useful when recommending a specific shelf-life and storage conditions. Although the long-term effect on the retention of vitamin D2 in UV-irradiated dried mushrooms, in particular button mushrooms, has not been well studied, the evidence from the current study suggests that sufficient vitamin D2 is present after 12 months of storage in darkness at 20–25 °C to be of nutritional significance.
The use of a validated analytical method that has been verified for a mushroom matrix was major strength of this study. In addition, there was a chain of custody from the farm to the laboratory, ensuring no unintended exposure to UV radiation. This was confirmed by analysing a fresh sample at the laboratory to ensure the concentrations of D-vitamers were below the LOQ. Although two different batches of mushrooms were analysed, they originated from the same farm under the same growing conditions, were irradiated and air dried with the same equipment and the same method and were analysed using the same method. The D vitamer concentrations measured prior to storage were similar in both batches. While pulsed UV lamps and machinery can initially be costly, the advantage of a pulsed radiation system is that the dose is consistent and can be varied depending on the concentration of D vitamers required. The D vitamers are generated in less than a second, while conventional UV lamps can take 30 min or more to generate a similar concentration. Therefore, the economics of commercially produced vitamin D-enriched mushrooms may favour the rapid throughput of pulse UV lamps.

5. Conclusions

Mushrooms are dried to increase the shelf life and make them easier to transport and store without refrigeration. UV-irradiated dried mushrooms are a good source of D vitamers. Vitamin D2 and 25(OH)D2 concentrations showed a gradual loss over 12 months, with the greatest rate of loss occurring during the latter 6 months. However, vacuum-sealed, UV-irradiated dried mushrooms kept at room temperature have a high retention of D-vitamers over 6 months after processing and packaging, a time span in which it is expected that most dried mushrooms would be cooked and consumed. Even after 12 months storage, UV-irradiated dried mushrooms still offered a valuable nutritional source of vitamin D2 in a 20 g serving size. As vitamin D deficiency is prevalent throughout the world, UV-irradiated dried mushrooms provide an opportunity to provide a convenient, long shelf-life source of vitamin D.

Author Contributions

G.C., conceptualization, investigation, writing—original draft preparation; J.F.B., supervision, review and editing; A.P.J., supervision, review and editing; A.D., formal analysis; E.D., review and editing; G.D., methodology; P.A., resources; L.J.B., supervision, review and editing. All authors have read and agreed to the published version of the manuscript.

Funding

This project was supported by the NHMRC (GNT1140611). G.C. was supported by the Australian Government Research Training Program Scholarship. L.J.B. is supported by MSWA and MS Australia.

Data Availability Statement

The data presented in this study are available upon request from the corresponding author. The data are not publicly available.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Herrick, K.A.; Storandt, R.J.; Afful, J.; Pfeiffer, C.M.; Schleicher, R.L.; Gahche, J.J.; Potischman, N. Vitamin D status in the United States, 2011–2014. Am. J. Clin. Nutr. 2019, 110, 150–157. [Google Scholar] [PubMed] [Green Version]
  2. Lips, P.; Cashman, K.D.; Lamberg-Allardt, C.J.E.; Bischoff-Ferrari, H.A.; Obermayer-Pietsch, B.; Bianchi, M.L.; Stepan, J.; Fuleihan, G.E.; Bouillon, R. Current vitamin D status in European and Middle East countries and strategies to prevent vitamin D deficiency: A position statement of the European Calcified Tissue Society. Eur. J. Endocrinol. 2019, 180, P23–P54. [Google Scholar] [PubMed] [Green Version]
  3. Ahmed, M.; Ng, A.P.; L’Abbe, M.R. Nutrient intakes of Canadian adults: Results from the Canadain Community Health Survey (CCHS)—2015 Public Use Microdata File. Am. J. Clin. Nutr. 2021, 114, 1131–1140. [Google Scholar]
  4. Dunlop, E.; Boorman, J.L.; Hambridge, T.L.; McNeill, J.; James, A.P.; Kiely, M.; Nowson, C.A.; Rangan, A.; Cunningham, J.; Adorno, P.; et al. Evidence of low vitamin D intakes in the Australian population points to a need for data-driven nutrition policy for improving population vitamin D status. J. Hum. Nutr. Diet. 2023, 36, 203–215. [Google Scholar] [PubMed]
  5. Cashman, K.D. Global differences in vitamin D status and dietary intake: A review of the data. Endocr. Connect. 2022, 11, e210282. [Google Scholar]
  6. Amrein, K.; Scherkl, M.; Hoffmann, M.; Neuwersch-Sommeregger, S.; Köstenberger, M.; Berisha, A.T.; Martucci, G.; Pilz, S.; Malle, O. Vitamin D deficiency 2.0: An update on the current status worldwide. Eur. J. Clin. Nutr. 2020, 74, 1498–1513. [Google Scholar]
  7. Cardwell, G.; Bornman, J.F.; James, A.P.; Black, L.J. A review of mushrooms as a potential source of dietary vitamin D. Nutrients 2018, 10, 1498. [Google Scholar]
  8. Nölle, N.; Argyropoulos, D.; Ambacher, S.; Muller, J.; Biesalski, H.K. Vitamin D2 enrichment in mushrooms by natural or artificial UV-light during drying. Food Sci. Technol. 2016, 85, 400–404. [Google Scholar]
  9. Urbain, P.; Valverde, J.; Jakobsen, J. Impact on vitamin D2, vitamin D4 and agaritine in Agaricus bisporus mushrooms after artificial and natural solar UV light exposure. Plant Foods Hum. Nutr. 2016, 71, 314–321. [Google Scholar]
  10. Keegan, R.J.; Lu, Z.; Bogusz, J.M.; Williams, J.E.; Holick, M.F. Photobiology of vitamin D in mushrooms and its bioavailability in humans. Dermatoendocrinology 2013, 5, 165–176. [Google Scholar]
  11. Putkaradze, N.; König, L.; Kattner, L.; Hutter, M.C.; Bernhardt, R. Highly regio- and stereoselective hydroxylation of vitamin D2 by CYP109E1. Biochem. Biophys. Res. Commun. 2020, 524, 295–300. [Google Scholar]
  12. Jenkinson, C. The vitamin D metabolome: An update on analysis and function. Cell Biochem. Funct. 2019, 37, 408–423. [Google Scholar]
  13. Cardwell, G.; Bornman, J.F.; James, A.P.; Daly, A.; Strobel, N.; Jakobsen, J.; Black, L.J. Effect of air-drying on the generation of vitamin D2 and 25-hydroxyvitamin D2 by pulsed UV irradiation in button mushroom (Agaricus bisporus). J. Food Compos. Anal. 2023, 115, 105034. [Google Scholar]
  14. Cashman, K.D.; Kiely, M.; Seamans, K.M.; Urbain, P. Effect of Ultraviolet Light-Exposed Mushrooms on Vitamin D Status: Liquid Chromatography-Tandem Mass Spectrometry Reanalysis of Biobanked Sera from a Randomized Controlled Trial and a Systematic Review plus Meta-Analysis. J. Nutr. 2016, 146, 565–575. [Google Scholar]
  15. Pinto, J.M.; Merzbach, V.; Willmott, A.G.B.; Antonio, J.; Roberts, J.S. Assessing the impact of a mushroom-derived food ingredient in vitamin D levels in healthy volunteers. J. Int. Soc. Sports Nutr. 2020, 54, 17. [Google Scholar]
  16. Schümmer, T.; Stangl, G.I.; Wätjen, W. Safety assessment of vitamin D and its photo-isomers in UV-irradiated baker’s yeast. Foods 2021, 10, 3142. [Google Scholar]
  17. Sławińska, A.; Fornal, E.; Radzki, W.; Skrzypczak, K.; Zalewska-Korona, M.; Michalak-Majewska, M.; Parfieniuk, E.; Stachniuk, A. Study on vitamin D2 stability in dried mushrooms during drying and storage. Food Chem. 2016, 199, 203–209. [Google Scholar]
  18. Gallotti, F.; Lavelli, V. The effect of UV irradiation on vitamin D2 content and antioxidant and antiglycation activities of mushrooms. Foods 2020, 9, 1087. [Google Scholar]
  19. Mattila, P.H.; Piironen, V.I.; Uusi-Rauva, E.J.; Koivistoinen, P.E. Vitamin D contents in edible mushrooms. J. Agric. Food Chem. 1994, 42, 2449–2453. [Google Scholar] [CrossRef]
  20. Keflie, T.S.; Nölle, N.; Lambert, C.; Nohr, D.; Biesalski, H.K. Impact of the natural resource of UVB on the content of vitamin D2 in oyster mushroom (Pleurotus ostreatus) under subtropical settings. Saudi J. Biol. Sci. 2019, 26, 1724–1730. [Google Scholar]
  21. Huang, G.; Cai, W.; Xu, B. Vitamin D2, ergosterol, and vitamin B2 content in commercially dried mushrooms marketed in China and increased vitamin D2 content following UV-C irradiation. Int. J. Vitam. Nutr. Res. 2016, 87, 237–246. [Google Scholar]
  22. Argyropoulos, D.; Heindl, A.; Müller, J. Assessment of convection, hot-air combined with microwave-vacuum and freeze-drying methods for mushrooms with regard to product quality. Int. J. Food Sci. Technol. 2011, 46, 333–342. [Google Scholar]
  23. Jaworska, G.; Pogoń, K.; Bernaś, E.; Skrzypczak, K. Effect of different drying methods and 24-month storage on water activity, rehydration capacity, and antioxidants in Boletus edulis mushrooms. Dry. Technol. 2014, 32, 291–300. [Google Scholar]
  24. Malik, M.A.; Jan, Y.; Haq, A.; Kaur, J.; Panda, B.P. Enhancement of vitamin D2 in edible mushroom using ultraviolet irradiation and assessing its storage and cooking stability. Nutr. Food Sci. 2022, 52, 1254–1269. [Google Scholar]
  25. Salemi, S.; Saedisomeolia, A.; Azimi, F.; Zolfigol, S.; Mohajerani, E.; Hohammadi, M.; Yaseri, M. Optimizing the production of vitamin D in white button mushrooms (Agaricus bisporus) using ultraviolet radiation and measurement of its stability. LWT Food Sci. Technol. 2021, 137, 110401. [Google Scholar]
  26. Kalaras, M.D.; Beelman, R.B.; Elias, R.J. Effects of postharvest pulsed UV light treatment of white button mushrooms (Agaricus bisporus) on vitamin D2 content and quality attributes. J. Agric. Food Chem. 2012, 60, 220–225. [Google Scholar]
  27. Guan, W.; Zhang, J.; Yan, R.; Shao, S.; Zhou, T.; Lei, J.; Wang, Z. Effects of UV-C treatment and cold storage on ergosterol and vitamin D2 contents in different parts of white and brown mushroom (Agaricus bisporus). Food Chem. 2016, 210, 129–134. [Google Scholar] [PubMed]
  28. Mattila, P.; Ronkainen, R.; Lehikoinen, K.; Piironen, V. Effect of Household Cooking on the Vitamin D content in Fish, Eggs, and Wild Mushrooms. J. Food Compos. Anal. 1999, 12, 153–160. [Google Scholar] [CrossRef]
  29. Chen, S.-Y.; Huang, S.-J.; Cheng, M.-C.; Chen, Y.-K.; Yang, S.-C.; Mau, J.-L. Enhancement of vitamin D2 content in Pleurotus mushrooms using pulsed light. J. Food Process. Preserv. 2015, 39, 2027–2034. [Google Scholar]
  30. International Organization for Standardization. ISO/IEC 17025; General Requirements for the Competence of Testing and Calibration Laboratories. International Organization for Standardization: London, UK; International Electrotechnical Commission: Geneva, Switzerland, 2017.
  31. Koyyalamudi, S.R.; Jeong, S.C.; Song, C.H.; Cho, K.Y.; Pang, G. Vitamin D2 formation and bioavailability from Agaricus bisporus button mushrooms treated with ultraviolet irradiation. J. Agric. Food Chem. 2009, 57, 3351–3355. [Google Scholar] [CrossRef]
  32. Perera, C.O.; Jasinghe, V.J.; Ng, F.L.; Mujumdar, A.S. The effect of moisture content on the conversion of ergosterol to vitamin D in Shiitake mushrooms. Dry. Technol. 2003, 21, 1091–1099. [Google Scholar]
  33. Ko, J.A.; Lee, B.H.; Lee, J.S.; Park, H.J. Effect of UV-B exposure on the concentration of vitamin D2 in sliced Shiitake mushroom (Lentinus edodes) and white button mushroom (Agaricus bisporus). J. Agric. Food Chem. 2008, 56, 3671–3674. [Google Scholar]
  34. Pedrali, D.; Gallotti, F.; Proserpio, C.; Pagliarini, E.; Lavelli, V. Kinetic study of vitamin D2 degradation in mushroom powder to improve its applications in fortified foods. LWT Food Sci. Technol. 2020, 125, 109248. [Google Scholar]
  35. National Health and Medical Research Council. Nutrient Reference Values for Australia and New Zealand; Commonwealth of Australia: Canberra, Australia, 2006.
  36. EFSA. Dietary Reference Values for Nutrients; Summary Report; European Food Safety Authority: Parma, Italy, 2017. [Google Scholar]
  37. Nordic Council of Ministers. Nordic Nutrition Recommendations 2012; Nordic Council of Ministers: Copenhagen, Denmark, 2014.
  38. Institute of Medicine. Dietary Reference Intakes for Calcium and Vitamin D; The National Academies Press: Washington, DC, USA, 2011. [Google Scholar]
  39. Heo, T.-Y.; Kim, Y.-N.; Park, I.B.; Lee, D.-H. Amplification of vitamin D2 in the white button mushroom (Agaricus bisporus) by UV-B radiation and jet-milling for its potential use as a functional ingredient. Foods 2020, 9, 1713. [Google Scholar]
  40. Turck, D.; Castenmiller, J.; de Henauw, S.; Hirsch-Ernst, K.; Kearney, J.; Maciuk, A.; Mangelsdorf, I.; McArdle, H.J.; Naska, A.; Pelaez, C.; et al. Scientific Opinion on the safety of vitamin D2 mushroom powder as a novel food pursuant to Regulation (EU) 2015/2283. EFSA J. 2020, 18, 5948. [Google Scholar]
  41. European Commission. Commission Implementing Regulation (EU) 2018/1011 of 17 July 2018 authorising an extension of use levels of UV-treated mushrooms as a novel food under Regulation (EU) 2015/2283 of the European Parliament and of the Council, and amending Commission Implementing Regulation (EU) 2017/2470 (Text with EEA relevance). Off. J. Eur. Union 2018, L 181/4–L 181/6. [Google Scholar]
Figure 1. Schematic overview of UV-irradiating, drying and extracting D vitamers from button mushrooms.
Figure 1. Schematic overview of UV-irradiating, drying and extracting D vitamers from button mushrooms.
Foods 12 01429 g001
Table 1. Retention of D vitamers in stored UV-irradiated, air-dried mushrooms.
Table 1. Retention of D vitamers in stored UV-irradiated, air-dried mushrooms.
Fresh Weight, g (Mean ± SD)Weight after Air-Drying, g% Loss 1 (Mean ± SD)Weight after Freeze-Drying, g% Loss 2 (Mean ± SD)D2 µg/g DW (Mean ± SD)25(OH)D2 µg/g DW (Mean ± SD)
Mushrooms Batch #1
Pulse irradiated, air dried, no storage (n = 4 × 200 g)201.9 ± 2.419.790.2 ± 0.217.791.2 ± 0.29.5 ± 1.4 a0.14 ± 0.03 a
Pulse irradiated, air dried, stored 12 months (n = 4 × 200 g)214.4 ± 6.421.390.4 ± 0.719.291.1 ± 0.45.5 ± 0.6 a
(57.7% retained)
0.10 ± 0.01 a
(67.9% retained)
Mushrooms Batch #2
Pulse irradiated, air dried, no storage (n = 4 × 200 g)213.3 ± 3.621.689.9 ± 0.219.890.8 ± 0.210.9 ± 0.40.16 ± 0.02 b
Pulse irradiated, air dried, stored 3 months (n = 4 × 200 g)219.1 ± 11.121.090.4 ± 0.719.891.0 ± 0.211.0 ± 0.8
(100.1% retained)
0.14 ± 0.01
(88.1% retained)
Pulse irradiated, air dried, stored 6 months (n = 4 × 200 g)217.6 ± 7.221.390.2 ± 1.220.090.8 ± 0.410.1 ± 0.6
(92.7% retained)
0.11 ± 0.01 b
(71.1% retained)
25(OH)D2, 25-hydroxyvitamin D2; DW, dry weight; LOQ, level of quantitation; SD, standard deviation. LOQ < 0.001 µg/g. 1 % weight loss in the air-dried samples compared to the fresh weight. 2 % weight loss in the freeze-dried samples compared to the fresh weight. a Statistically significant difference (p < 0.05) between 0 and 12 months of storage. b Statistically significant difference (p < 0.05) between 0 and 6 months of storage.
Disclaimer/Publisher’s Note: The statements, opinions and data contained in all publications are solely those of the individual author(s) and contributor(s) and not of MDPI and/or the editor(s). MDPI and/or the editor(s) disclaim responsibility for any injury to people or property resulting from any ideas, methods, instructions or products referred to in the content.

Share and Cite

MDPI and ACS Style

Cardwell, G.; Bornman, J.F.; James, A.P.; Daly, A.; Dunlop, E.; Dabos, G.; Adorno, P.; Black, L.J. The Retention of Vitamin D2 and 25-Hydroxyvitamin D2 in Pulse UV-Irradiated Dried Button Mushrooms (Agaricus bisporus) after 12 Months of Storage. Foods 2023, 12, 1429. https://doi.org/10.3390/foods12071429

AMA Style

Cardwell G, Bornman JF, James AP, Daly A, Dunlop E, Dabos G, Adorno P, Black LJ. The Retention of Vitamin D2 and 25-Hydroxyvitamin D2 in Pulse UV-Irradiated Dried Button Mushrooms (Agaricus bisporus) after 12 Months of Storage. Foods. 2023; 12(7):1429. https://doi.org/10.3390/foods12071429

Chicago/Turabian Style

Cardwell, Glenn, Janet F. Bornman, Anthony P. James, Alison Daly, Eleanor Dunlop, Georgios Dabos, Paul Adorno, and Lucinda J. Black. 2023. "The Retention of Vitamin D2 and 25-Hydroxyvitamin D2 in Pulse UV-Irradiated Dried Button Mushrooms (Agaricus bisporus) after 12 Months of Storage" Foods 12, no. 7: 1429. https://doi.org/10.3390/foods12071429

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop